2012 Freightliner Cascadia recalls

• Lights And Instruments#2020158April 14, 2020

  873 units affected

  Issue: On certain trucks equipped with "Fleet Engineer" mud flaps, the bracket for the mud flaps may partially cover the rear reflective tape. Canadian regulations require that reflective tape must be visible on the rear of the truck. Safety Risk: Reflective tape that is covered may make the truck less visible to others and could create an increased risk of a crash. Corrective Actions: Daimler Trucks of North America (DTNA) will notify owners by mail and instruct you to take your truck to an authorized DTNA Service Facility to inspect the reflective tape. It will be moved as necessary to meet the regulations.

• Suspension#2018395July 30, 2018

  32 units affected

  On certain trucks, a combination of brake vibrations and corrosion could cause the tie-rod tube to fatigue and break. This may lead to a disconnect between the front wheels and reduce the ability to steer the vehicle, which could increase the risk of a crash causing injury and/or damage to property. Correction: Daimler Trucks of North America Service Facilities will replace brake linings, brake spiders and tie rods as necessary.

• Brakes#2017583November 28, 2017

  41,763 units affected

  On certain vehicles with air brakes, after several hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal. If the brake lights do not illuminate, following road users would be unaware of the intent of the driver to slow the vehicle, which could increase the risk of a crash causing injury and/or damage to property. Correction: Daimler Trucks North America authorized service facilities will repair the brake light pressure switch.

• Structure#2015486October 16, 2015

  13 units affected

  On certain vehicles, the fifth wheel locking mechanisms could be susceptible to damage and/or wear. This could cause the locking mechanism to fail properly engage, potentially resulting in a towed trailer unit separating from the truck tractor. As a result, the trailer could strike another vehicle, stationary object, or bystander, causing injury and/or damage to property. Correction: Fontaine dealers will replace all Ultra LT fifth wheel units with Ultra NT model fifth wheel units.

• Other#2012442December 21, 2012

  7 units affected

  On certain trucks, the bottom access panel may dislodge and separate from the Thermo King Tripac Auxiliary Power Unit (APU). A panel separating from the vehicle could strike another vehicle, a stationary object, or bystander, causing property damage and/or personal injury. Correction: Thermo King authorized service facilities will inspect and, if necessary, replace the APU’s access panel.

• Brakes#2012281August 15, 2012

  147 units affected

  On certain trucks, the air tank mounting brackets may crack, which could allow the tank to detach from the vehicle. An air tank separating from the vehicle could strike another vehicle, a stationary object, or a bystander. As well, loss of an air tank would cause a loss of service brakes, which could increase stopping distances, possibly causing a crash. These issues could result in property damage and/or personal injury. Correction: Dealers will replace the air tank mounting brackets.

• Brakes#2012139April 23, 2012

  179 units affected

  On certain trucks, the quick release valve (QRV) cover may not have been welded correctly during manufacturing process and may become loose or separate from the valve body. If this occurs, air pressure may not be supplied to the front brakes during brake application. The rear brakes will continue to function. Reduction in braking efficiency could increase stopping distances, possibly resulting in a crash causing property damage and/or personal injury. Correction: Daimler authorized repair facilities will inspect and if necessary replace the quick release valve.

• Steering#2012119March 30, 2012

  256 units affected

  On certain vehicles, an incorrect steering wheel fastener may have been installed during vehicle assembly. The incorrect nut may not provide the clamp load required to fully seat the steering wheel onto the steering shaft. This could allow the steering wheel to wobble, which could hamper vehicle operation. If the problem is ignored, the nut could loosen completely, which could allow the steering wheel to detach from the steering shaft. These issues could result in a crash causing property damage and/or personal injury. Correction: Dealers will replace the steering wheel nut.

• Seats And Restraints#2012113March 30, 2012

  248 units affected

  On certain vehicles, the driver's seat base may not have been manufactured correctly and could fail. This could allow the seat to lower unexpectedly. Should this occur while the vehicle is in motion, it could result in a crash causing property damage and/or personal injury. Correction: Dealers will replace the driver's seat base.

• Fuel System#2012080February 27, 2012

  11,923 units affected

  On certain trucks equipped with a Detroit Diesel DD13, DD15 or DD16 engine, the support system for the high pressure fuel line (between the fuel pump and the fuel delivery rail) may be damaged during a service repair procedure. Incorrect torque applied to the dampener "P" clip fasteners may damage the fasteners, which could allow the clips to loosen. This could result in a cracked fuel line and a diesel fuel leak. Diesel fuel leakage may ignite on a hot engine surface and cause a fire. As well, diesel fuel spilt on the roadway could endanger other road users by making the roadway unexpectedly slippery. These issues could result in property damage and/or personal injury. Correction: Dealers will replace the high pressure fuel line and install a more robust fuel line support system.

• Other#2011346September 19, 2011

  1,027 units affected

  On certain vehicles, specific operating conditions (such as tight, successive, highly banked curves in opposite directions), could trigger unintended Electronic Stability Control (ESC) system intervention. As a result, the ESC may unnecessarily apply one of the front brakes in order to correct the perceived oversteer condition. This may cause the vehicle to deviate from the intended path, thereby increasing the risk of a crash causing property damage and/or personal injury. Correction: Dealers will replace the ESC module.

• Electrical#2011236June 22, 2011

  5,924 units affected

  On certain trucks equipped with a DD15 or DD16 engine, the bolt attaching a rubber isolator to a support bracket may become loose, back out, and contact the starter cable. This could cause an electrical short, which could result in a fire causing property damage and/or personal injury. Correction: Dealers will install a new bolt and isolator, and apply thread-locking fluid to the fastener.

• Powertrain#2011172April 27, 2011

  81 units affected

  On certain trucks, the driveshaft may not have been welded correctly during the manufacturing process. This could allow the driveshaft to fracture along the length of the tube seam weld when torque is applied. The fractured tube can twist or sever, which could result in additional damage to the driveline, the vehicle to which it is attached, and any additional nearby components. Should the brake air lines become damaged, it could allow spring brake application, causing immediate brake lock-up. If this occurs while the vehicle is in motion, it could result in a crash. Also, failure of the driveshaft would result in lost vehicle propulsion which, in conjunction with traffic and road conditions, and the driver's reactions, could increase the risk of a crash. Either condition could result in property damage and/or personal injury. Correction: Dealers will replace the driveshaft assembly.

Canadian data updated August 24, 2026

• EXTERIOR LIGHTING#20V214000April 14, 2020

  Daimler Trucks North America LLC (DTNA) is recalling certain 2006-2020 Freightliner Columbia, 2006-2021 Freightliner Business Class M2, 2007-2020 Freightliner Coronado, 2014-2021 Freightliner 122 SD, 2007 Sterling A 9500, 2006 Freightliner Argosy, 2006-2007 Sterling AT9500, 2008-2021 Freightliner Cascadia, 2006-2008 Freightliner Classic, 2006-2011 Freightliner Century Class, 2006-2010 Freightliner FLD, and 2017 Western Star 5700 vehicles. The rear reflective tape may be partially covered by the mudflap hanger bracket, which may reduce the vehicle's visibility to other drivers on the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

  Risk: The vehicle's rearward visibility may be reduced, increasing the risk of a crash.

  Remedy: DTNA will notify owners, and dealers will inspect and reposition the reflective tape to ensure that it is completely visible, as necessary, free of charge. The recall began May 29, 2020. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL848.

• STEERING:LINKAGES:TIE ROD ASSEMBLY#18V503000July 31, 2018

  Daimler Trucks North America, LLC (DTNA) is recalling certain 2012-2015 Freightliner Cascadia, Coronado, Business Class M2, 114SD, and Western Star 4900 trucks. In certain front axle, brake lining, and brake spider combinations, braking may cause high vibrations, resulting in early failure of the tie-rod tube.

  Risk: A tie-rod failure would cause a disconnect between the front wheels, resulting in a loss of steering ability, thereby increasing the risk of a crash.

  Remedy: DTNA will notify owners, and dealers will replace the brake linings, brake spider, and tie-rod, free of charge. The recall began March 22, 2019. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL782.

• EQUIPMENT#17V810000December 15, 2017

  Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

  Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

  Remedy: DTNA will notify owners, and instruct them to contact Kidde for a replacement fire extinguisher, free of charge. The recall began on April 11, 2018. Owners may contact DTNA customer service at 1-800-547-0712, or contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information. DTNA's number for this recall is FL-759.

• EXTERIOR LIGHTING:BRAKE LIGHTS#17V761000November 28, 2017

  Daimler Trucks North America, LLC (DTNA) is recalling certain 2008-2018 Freightliner Cascadia, Western Star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.

  Risk: If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.

  Remedy: DTNA will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on January 22, 2018. The recall began on May 9, 2018. Owners may contact DTNA customer service at 1-800-547-0712. DTNA's number for this recall is FL-756.

• TRAILER HITCHES:FIFTH WHEEL ASSEMBLY#15V616000October 1, 2015

  Daimler Trucks North America LLC (DTNA) is recalling certain model year 2011-2014 Cascadia, Business Class M2, Coronado, and Columbia Glider vehicles manufactured April 5, 2010, to June 15, 2013. The affected trucks are equipped with Fontaine Ultra LT Fifth Wheel connectors, which, due to cumulative damage to the fifth wheel and its locking mechanism, have a locking mechanism that may fail to operate or to properly engage.

  Risk: If the fifth wheel and locking mechanism are sufficiently damaged, the locking mechanism may fail to operate as intended and the trailer may unexpectedly detach from the tractor, increasing the risk of a crash.

  Remedy: DTNA will notify owners, and DTNA authorized service facilities will replace the fifth wheel with an Ultra NT model fifth wheel, free of charge. The recall began on November 20, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-692.

• ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE#14V680000October 29, 2014

  Daimler Trucks of North America LLC (DTNA) is recalling certain model year 2011-2015 Freightliner Cascadia and M2 trucks manufactured June 2, 2011 to October 23, 2014. The vehicles are not in compliance with the requirements of the Federal Motor Vehicle Safety Standards No. 303, "Fuel System Integrity Of Compressed Natural Gas Vehicles." Specifically, the tail pipe on these vehicles terminates under the compressed natural gas (CNG) tank and can overheat the fuel system.

  Risk: Due to the area of its placement, the exhaust system forces heat around, and may overheat, the fuel system components, increasing the risk of a vehicle fire.

  Remedy: DTNA will notify owners, and dealers will extend the tailpipe beyond the cabinet, free of charge. The recall began Feburary 12, 2015. Owners may contact DTNA customer service at 1-800-745-8000. DTNA's number for this recall is FL-671.

• ENGINE AND ENGINE COOLING:ENGINE#14V080000February 21, 2014

  Daimler Trucks North America LLC (Daimler) is recalling certain model year 2008-2015 Freightliner 114SD, Cascadia, M2 Business Class, Sterling LT8500, and Thomas Built Buses Saf-T-Liner HDX vehicles manufactured February 19, 2008, through February 11, 2014, and equipped with Cummins Westport Model ISL G and Cummins Westport Model ISX12 G engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.

  Risk: The sensor malfunction could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.

  Remedy: Cummins and Cummins Westport will notify owners, and authorized Cummins service facilities will upload a new ECM calibration, free of charge. The recall began on April 12, 2014. Customers may contact Daimler at 1-800-385-4357 or Cummins Inc. at 1-800-343-7357. Daimler's number for this recall is FL-660.

• ELECTRICAL SYSTEM:SOFTWARE#13V127000April 9, 2013

  Daimler Trucks North America (DTNA) is recalling certain model year 2012-2014 Cascadia and Coronado vehicles manufactured between November 21, 2011, and April 3, 2013. In the affected vehicles, when the ignition is off and the door is opened without the parking brake applied, the dashboard does not display the correct message of "Park Brake Off Door Open."

  Risk: Without the proper warning, a driver may not be reminded to apply the parking brake which may lead to a vehicle roll away, increasing the risk of a crash.

  Remedy: DTNA will notify owners, and dealers will update then display software. The safety recall began on June 6, 2013. Owners may contact DTNA at 1-800-547-0712. Daimler's recall campaign number is FL-642.

• EXTERIOR LIGHTING#13V099000March 18, 2013

  Daimler Trucks North America (DTNA) is recalling certain model year 2012-2014 Freightliner Cascadia tractors manufactured from April 12, 1210, through March 2, 2013, and equipped with a SAMCAB software version 6.2. On vehicles configured to have the turn signals operate as Daytime Running Lights (DRLs) and the 'Turn-Tip' turn signal function activated, the DRLs may not illuminate properly after using the 'Turn-Tip' function while driving.

  Risk: Failure of the DRLs to illuminate reduces visibility to other drivers and increases the risk of a vehicle crash.

  Remedy: DTNA sent notification to owners on May 6, 2015, instructing them to contact their dealers and arrange to have the free SAMCAB software updated to correct the operation of the DRLs and "Turn Tip" feature. Owners may contact DTNA at 1-800-547-0712.

• EQUIPMENT#12V601000December 21, 2012

  Daimler Trucks North America (DTNA) is recalling certain model year 2012 Cascadia and Coronado tractor trailers manufactured from August 1, 2011, through December 30, 2011, equipped with Thermo King TriPac Auxiliary Power Units (APU), serial numbers 3000106335 to 3000127584, manufactured from July 29, 2011, through November 7, 2011. The maintenance access panel door on the bottom of the APU may dislodge and separate.

  Risk: If the door separates from the APU while the vehicle is being driven, it may create a road hazard for other drivers.

  Remedy: DTNA will notify owners, and Thermo King dealers will inspect the APUs and replace any of the affected panel doors free of charge. The recall began February 25, 2013. Owners may contact DTNA at 1-800-547-0712.

• EQUIPMENT#12V405000August 16, 2012

  Daimler Trucks North America (DTNA) is recalling certain model year 2009-2012 Freightliner, Sterling, and Western Star vehicles manufactured from July 7, 2008, through December 15, 2011, and equipped with perpendicular air tank mounting brackets. The air tank mounting brackets may develop cracks which can lead to the air tank brackets separating from the frame rail. The air tanks may also separate from the vehicle.

  Risk: Air tanks that become separated from a moving vehicle may create a road debris hazard, increasing the risk of a crash.

  Remedy: DTNA will notify owners, and dealers will replace the air mounting brackets, free of charge. The recall began on December 24, 2012. Owners may contact Daimler Trucks North America toll free at 1-800-547-0712.

• SERVICE BRAKES, AIR:SUPPLY:QUICK RELEASE VALVE#12V178000April 24, 2012

  DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2012-2013 FREIGHTLINER 108SD, BUSINESS CLASS M2, CASCADIA, CORONADO VEHICLES, EQUIPPED WITH A HALDEX QUICK RELEASE VALVE, AND MANUFACTURED FROM FEBRUARY 3, 2012, THROUGH MARCH 2, 2012. THE QUICK RELEASE VALVE COVER MAY NOT BE CORRECTLY MANUFACTURED, ALLOWING THE COVER TO BECOME SEPARATED FROM THE VALVE BODY. IF THE COVER SEPARATES FROM THE VALVE BODY, THE FRONT BRAKES MAY NOT FUNCTION.

  Risk: IF THIS CONDITION OCCURS, INCREASED VEHICLE STOPPING DISTANCE MAY RESULT, INCREASING THE RISK OF A CRASH.

  Remedy: DTNA WILL NOTIFY OWNERS, AND WHERE NECESSARY, THE QUICK RELEASE VALVE WILL BE REPLACED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN BEFORE JUNE 15, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

• STEERING:COLUMN#12V137000April 2, 2012

  DAIMLER TRUCKS (DTNA) IS RECALLING ONE 2012 CASCADIA AND CERTAIN MODEL YEAR 2012 AND 2013 FREIGHTLINER BUSINESS CLASS M2 VEHICLES, AND MODEL YEAR 2013 108SD AND 114SD VEHICLES MANUFACTURED FROM JANUARY 20, 2012, THROUGH FEBRUARY 17, 2012. CERTAIN PROPERTY CLASS 04 (PC04) STEERING WHEEL NUTS WITH INCOMPLETELY FORMED THREADS WERE SUPPLIED TO DTNA IN LIEU OF THE SPECIFIED PROPERTY CLASS 05 NUTS. THE STEERING WHEEL NUTS SUPPLIED MAY NOT PROVIDE THE CLAMP LOAD REQUIRED TO FULLY SEAT THE STEERING WHEEL ON THE STEERING SHAFT WHEN TIGHTENED TO THE SPECIFIED TORQUE.

  Risk: A STEERING WHEEL THAT IS NOT FULLY SEATED ON THE STEERING SHAFT MAY WOBBLE AND MAKE IT DIFFICULT TO CONTROL THE VEHICLE, INCREASING THE RISK OF A CRASH.

  Remedy: DTNA WILL NOTIFY OWNERS, AND AFFECTED VEHICLES WILL HAVE A NEW STEERING WHEEL NUT INSTALLED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 21, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

• SEATS#12V138000April 2, 2012

  DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2012 FREIGHTLINER CASCADIA AND WESTERN STAR 4900 VEHICLES, MANUFACTURED FROM DECEMBER 22, 2011, THROUGH FEBRUARY 23, 2012. THESE VEHICLES MAY BE EQUIPPED WITH CERTAIN NATIONAL SEAT BRAND DRIVER’S SEATS. THESE SEAT BASES MAY HAVE OUT-OF-SPECIFICATION WELDS THAT MAY ALLOW THE SEAT TO BUCKLE UNEXPECTEDLY.

  Risk: AN UNEXPECTED MOVEMENT OF THE SEAT COULD AFFECT VEHICLE CONTROL AND VISIBILITY, INCREASING THE RISK OF A CRASH.

  Remedy: DTNA WILL NOTIFY OWNERS, AND AFFECTED VEHICLES WILL HAVE REPLACEMENT COMPONENTS INSTALLED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. AN INTERIM LETTER WAS MAILED TO OWNERS ON MAY 16, 2012. THE RECALL TO PERFORM THE FINAL REMEDY BEGAN ON NOVEMBER 21, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

• ENGINE AND ENGINE COOLING:ENGINE:DIESEL#12V074000February 28, 2012

  DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.

  Risk: A FUEL LEAK COULD CREATE A ROAD HAZARD, INCREASING THE RISK OF A CRASH. ALSO A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.

  Remedy: DTNA WILL NOTIFY OWNERS, AND WHERE NECESSARY, THE HIGH PRESSURE FUEL LINE SUPPORT SYSTEM WILL BE REPLACED BY DTNA AUTHORIZED SERVICE FACILITIES, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 27, 2012. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

• ELECTRONIC STABILITY CONTROL (ESC)#11V465000September 8, 2011

  DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006-2012 FREIGHTLINER BUSINESS CLASS M2, CASCADIA, CENTURY, COLUMBIA, CORONADO AND STERLING A-LINE VEHICLES BUILT WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) SYSTEM MANUFACTURED FROM SEPTEMBER 15, 2005 THROUGH SEPTEMBER 1, 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.

  Risk: IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL INCREASING THE RISK OF A CRASH.

  Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE ESC MODULE WITH THE APPROPRIATE SOFTWARE VERSION AS NECESSARY, FREE OF CHARGE. AN INTERIM OWNER NOTIFICATION WILL BE MAILED ON OR ABOUT NOVEMBER 21, 2011. THE DATE FOR AVAILABILITY OF THE FINAL REMEDY IS SUBJECT TO VALIDATION TESTING AND PARTS AVAILABILITY. THE SAFETY RECALL BEGAN ON MARCH 28, 2012. OWNERS MAY CONTACT DAIMLER TRUCKS TOLL-FREE AT 1-800-547-0712.

• ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES#11V330000June 21, 2011

  DTNA IS RECALLING CERTAIN MODEL YEAR 2008-2012 FREIGHTLINER; CASCADIA, CENTURY CLASS, COLUMBIA, AND CORONADO, CERTAIN MODEL YEAR 2008-2009 STERLING; A-LINE AND L-LINE AND CERTAIN MODEL YEAR 2009-2012 WESTERN STAR CONSTELLATION VEHICLES, MANUFACTURED FROM JANUARY 14, 2008, THROUGH JUNE 15, 2011, BUILT WITH DETROIT DIESEL 15 OR 16 ENGINES. THE BOLT ATTACHING A RUBBER ISOLATOR TO A SUPPORT BRACKET MAY BECOME LOOSE AND BACK OUT, POTENTIALLY CONTACTING AN UN-FUSED STARTER CABLE AND CREATING A SHORT CIRCUIT.

  Risk: A SHORT CIRCUIT BETWEEN AN UN-FUSED BATTERY CABLE AND CHASSIS GROUND COULD RESULT IN A VEHICLE FIRE.

  Remedy: DEALERS WILL INSTALL A NEW BOLT AND ISOLATOR AND REPAIR THE RECREATIONAL VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 21, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

• TRAILER HITCHES:FIFTH WHEEL ASSEMBLY#11V289000May 18, 2011

  DTNA IS RECALLING CERTAIN MODEL YEAR 2011 BUSINESS CLASS M2, AND CORONADO, MODEL YEAR 2011-2012 CASCADIA VEHICLES EQUIPPED WITH FONTAINE ULTRA LT FIFTH WHEELS AND MANUFACTURED FROM APRIL 7, 2010, THROUGH MARCH 7, 2011. DURING THE COUPLING PROCESS ON VEHICLES EQUIPPED WITH PRE-MODIFICATION FONTAINE ULTRA LT FIFTH WHEELS, IT IS POSSIBLE FOR THE DRIVER TO PARTIALLY CLOSE THE FIFTH WHEEL LOCK, AND IF RELYING ON A TUG TEST (PULL TEST), AND NOT PERFORMING THE REQUIRED VISUAL INSPECTION, THINK THAT THE FIFTH WHEEL LOCK IS PROPERLY COUPLED TO THE TRAILER KING PIN, WHEN IN FACT, IT IS NOT.

  Risk: IF THE TRACTOR IS NOT FULLY CONNECTED TO THE TRAILER, THE TRAILER MAY DISENGAGE WHILE IN USE, INCREASING THE RISK OF A CRASH.

  Remedy: FONTAINE NOTIFIED OWNERS IN FEBRUARY 2011, AND IS HANDLING THE REMEDY FOR THIS CAMPAIGN. FONTAINE IS IN THE PROCESS OF RETROFITTING ALL AFFECTED VEHICLES, FREE OF CHARGE. OWNERS MAY CONTACT FONTAINE AT 1-800-874-9780 OR DTNA AT 1-800-547-0712.

• POWER TRAIN:DRIVELINE#11V257000April 26, 2011

  DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2011-2012 FREIGHTLINER CASCADIA, M2, AND WESTERN STAR 4900 VEHICLES, MANUFACTURED FROM JANUARY 11, 2011, THROUGH FEBRUARY 21, 2011, AND EQUIPPED WITH A MERITOR DRIVELINE. THE TUBING USED TO ASSEMBLE THE AFFECTED DRIVELINES HAS A NONCONFORMING SEAM WELD WITH INSUFFICIENT BONDING OF THE MATERIAL.

  Risk: A TUBE SEAM WELD THAT IS NOT PROPERLY BONDED CAN RESULT IN THE DRIVELINE ASSEMBLY FRACTURING ALONG THE LENGTH OF THE TUBE SEAM WELD. THE FRACTURED TUBE CAN TWIST OR SEVER. THIS COULD RESULT IN ADDITIONAL DAMAGE TO THE DRIVELINE, THE VEHICLE TO WHICH IT IS ATTACHED AND ANY ADDITIONAL NEARBY COMPONENTS. THIS MAY INCREASE THE RISK OF A CRASH.

  Remedy: DEALERS WILL REPLACE THE DRIVELINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 27, 2011. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.