2014 Chevrolet Malibu recalls

• Other#2019420August 21, 2019

  5,327 units affected

  Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.

• Structure#2015118March 18, 2015

  4,927 units affected

  Certain vehicles equipped with power-operated sunroof systems may fail to conform to Canada Motor Vehicle Safety Standard (CMVSS) 118 - Power-Operated Window, Partition and Roof Panel Systems. The roof panels could close automatically when the non-recessed portion of the “Slide” or “Tilt” switches are pressed and the roof panel is open, which is contrary to the standard. The switch could be more susceptible to an inadvertent actuation, which could result in unintended auto-closure of the roof panel, increasing the risk of injury. Correction: Dealers will update the Body Control Module (BCM), which will remove the "one touch" (momentary actuation) feature for certain switch positions.

• Brakes#2014171May 14, 2014

  3,550 units affected

  Certain vehicles equipped with a 2.5L engine and Auto Stop/Start fail to comply with the requirements of Canada Motor Vehicle Safety Standard 135 - Light Vehicle Brake Systems. If the vehicle experiences a complete loss of brake vacuum assist, the hydraulic boost assist can be disabled, which would cause the vehicle to fail to meet the requirements of the standard. This would also increase brake pedal effort and vehicle's stopping distance, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will update recalibrate the electronic brake control module.

• Brakes#2014168May 9, 2014

  209 units affected

  On certain vehicles, the front brake assembly may have been equipped with a rear brake rotor instead of a front one. During braking, higher heat will be generated by the thinner rear brake rotor which will significantly shorten the brake pad life. As the pads and rotor wear, the outer brake pad may come disengaged resulting in reduced brake system performance increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect both front brake rotors, and install new rotors and brake pads if necessary.

• Powertrain#2014054February 25, 2014

  21 units affected

  Certain vehicles equipped with automatic transmissions may fail to conform to Canada Motor Vehicle Safety Standard (CMVSS) 102 - Transmission Control Functions and CMVSS 114 - Theft Protection and Rollaway Prevention. The shift cable adjuster may have been damaged at time of assembly and could disengage, causing the transmission to remain in a gear position different from the one indicated in the instrument panel. If the shift cable were to disengage while driving, upon stopping the vehicle, a driver could move the transmission range selector lever to the PARK position and remove the key, without the transmission being in PARK. If the parking brake is not set, the vehicle could roll, potentially resulting in a crash increasing the risk of injury and/or property damage. Correction: Dealers will inspect and install a revised adjuster and clip if necessary.

• Heater And Defroster#2013402November 13, 2013

  1,034 units affected

  Certain vehicles may not comply with Canada Motor Vehicle Safety Standard 103 - Windshield Defrosting and Defogging. The heating, ventilation and air conditioning (HVAC) controls in these vehicles may intermittently become inoperable when the vehicle is started. If this occurs, the HVAC system will remain on the previous settings in place at the time the vehicle was shut off. This could interfere with windshield defrosting and/or defogging, causing reduced visibility and increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will reprogram the electronic climate control module.

Canadian data updated August 24, 2026

• ELECTRICAL SYSTEM:IGNITION#16V502000July 5, 2016

  General Motors LLC (GM) is recalling certain model year 2016-2017 Buick Verano and 2016 Chevrolet Malibu as the electronic park lock lever may allow the ignition key to be removed without the transmission being in PARK. Also, certain 2013 Buick Encore, 2011 Buick Regal, 2013-2014 Buick Verano, 2011-2016 Chevrolet Cruze, 2010-2013 Chevrolet Equinox 2013-2015 Chevrolet Malibu, and 2011-2013 GMC Terrain vehicles may have been serviced with similar defective replacement electronic park lock levers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection and Rollaway Prevention."

  Risk: If the key is removed without the transmission in PARK, the vehicle may rollaway as occupants are exiting, increasing the risk of injury.

  Remedy: GM will notify owners, and dealers will inspect and if necessary replace the key cylinder lock housing, free of charge. The recall began on October 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick 1-800-521-7300, and GMC 1-800-462-8782. GM's number for this recall is 50490 and 50491.

• VISIBILITY:SUN/MOON ROOF ASSEMBLY#15V164000March 23, 2015

  General Motors LLC (GM) is recalling certain model year 2013-2015 Chevrolet Malibu vehicles October 24, 2011, to March 5, 2015. In the affected vehicles, the Slide or Tilt switch for the roof panel may not be adequately recessed to prevent the switch from inadvertently being pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 118, "Power-Operated Window, Partition, and Roof Panel Systems."

  Risk: The Slide or Tilt roof panel switch may inadvertently be pressed and the roof panel may auto-close unexpectedly, increasing the risk of a pinch injury.

  Remedy: GM will notify owners, and dealers will update the Body Control Module (BCM) software to remove auto-close feature for certain switch positions, free of charge. The recall began April 21, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15176.

• SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM#14V247000May 14, 2014

  General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Malibu vehicles manufactured June 12, 2013, through May 2, 2014, and equipped with a 2.5L engine with the auto stop/start option. The affected vehicles may experience a complete loss of brake vacuum assist, disabling the hydraulic boost assist. As such, these vehicles do not comply with Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."

  Risk: If the hydraulic boost assist is disabled, slowing or stopping the vehicle will require additional brake pedal effort and a lengthened stopping distance. Both of these effects increase the risk of a crash.

  Remedy: GM will notify owners, and dealers will update the electronic brake control module software, free of charge. The recall began on July 3, 2014. Owners may contact General Motors customer service at 1-800-222-1020. General Motors number for this recall is 14201.

• SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC#14V240000May 8, 2014

  General Motors LLC (GM) is recalling certain model year 2014 Buick Lacrosse vehicles manufactured January 29, 2014, through March 31, 2014 and 2014 Chevrolet Malibu vehicles manufactured February 7, 2014, through March 31, 2014, and equipped with 17 inch front brake rotors. The affected vehicles may have had brake rotors intended for the rear of the car accidentally installed on the front. The rear rotors, while the same diameter, are thinner and may result in a front brake pad detaching from the caliper.

  Risk: If a brake pad detaches from caliper, there may be a sudden reduction in braking, lengthening the distance required to stop the vehicle and increasing the risk of a crash.

  Remedy: GM will notify owners, and dealers will inspect the front brake rotors, and install the correct rotors with new brake pads, as necessary, free of charge. The recall began on June 20, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick) or 1-800-222-1020 (Chevrolet). GM's number for this recall is 14128.

• POWER TRAIN:AUTOMATIC TRANSMISSION#14V092000February 21, 2014

  General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."

  Risk: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.

  Remedy: General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall began on April 10, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.

• VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM#13V567000November 13, 2013

  General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Malibu vehicles manufactured June 12, 2013, through November 5, 2013. The heating, ventilation, and air conditioning (HVAC) control in these vehicles may intermittently become inoperable when the vehicle is started, preventing the windshield defroster from working. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 103, "Windshield Defrosting and Defogging Systems."

  Risk: The inability to turn on the windshield defroster may decrease the driver's visibility thereby increasing the risk of a crash.

  Remedy: GM will notify owners, and dealers will update the electronic climate control module software, free of charge. The recall began during December 2013. Owners may contact GM at 1-800-521-7300. GM's recall campaign number is 13380.