2010 Volvo XC60 recalls

• Seats And Restraints#2020298June 30, 2020

  24,089 units affected

  Issue: On certain vehicles, the flexible steel cable that attaches the seat belt to the outside of the front seats may weaken over time. As a result, the seat belt could detach. Safety Risk: A seat belt that detaches in a crash could create an increased risk of injury. Corrective Action: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to replace the front-outboard seat belt anchors.

• Seats And Restraints#2010423November 23, 2010

  1,319 units affected

  On certain vehicles equipped with power front passenger seats, the "end stops" on the seat frame rails may be missing. If the end stops are missing, the maximum allowable seat travel may be exceeded, resulting in an increased injury risk for out of position occupants in the event of a frontal collision. Correction: Dealers will inspect the front seat rails for the presence of an "end stop", and install one if necessary.

• Airbag#2010397November 10, 2010

  8 units affected

  On certain vehicles, the inflatable curtains (lateral airbags) may have manufactured incorrectly. Failure of the inflatable curtain to fully deploy during a crash *where deployment is warranted) could increase the risk of personal injuries to the seat occupant. Correction: Dealers will inspect the left and right inflatable curtain assemblies and adjust them if necessary.

• Fuel System#2009350December 15, 2009

  801 units affected

  On certain vehicles, the fuel line rail cover that protects the fuel lines under the car, may not be properly attached. If the cover is not properly secured the fuel lines may become exposed and may become damaged. Damaged fuel lines may result in a fuel leak causing fire, personal injury or death. Correction: Dealers will inspect and, if necessary, reattach the fuel line rail.

• Other#2009334November 19, 2009

  1,207 units affected

  On certain vehicles, the driver's seat side cover panel (seat control panel) may compromise the functionality of the seatbelt during certain driver's side crashes. Should this occur, the seatbelt anchor point may disengage, increasing the risk of personal injury or death. Correction: Dealers will modify the driver's seat side cover panel.

• Fuel System#2009255September 8, 2009

  1,272 units affected

  On certain vehicles, the software within the Central Electronic Module (CEM) may not send a signal to the fuel Pump Electronic Module (PEM). This missing signal to the PEM inhibits the start of the fuel pump. The driver may be able to start the engine in spite of the fuel pump not being activated due to residual pressure in the fuel system. In some cases, the driver may be able to drive the vehicle a short distance at idle. However, the engine will eventually stall. Engine stalling would result in lost propulsion which, in conjunction with traffic and road conditions, and the driver's reactions, could increase the risk of a crash. Correction: Dealers will upgrade the CEM software.

Canadian data updated August 24, 2026

• SEAT BELTS:FRONT#20V378000June 30, 2020

  Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.

  Risk: An unsecured occupant has an increased risk of injury in the event of a crash.

  Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.

• SEATS#10V591000November 22, 2010

  VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.

  Risk: POSITIONING OF THE SEAT BEYOND THE INTENDED MAXIMUM CAN CAUSE INCREASED RISK OF INJURY TO THE PASSENGER IN THE EVENT OF A CRASH.

  Remedy: DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.

• AIR BAGS#10V564000November 10, 2010

  VOLVO IS RECALLING CERTAIN MODEL YEAR 2010 XC60 VEHICLES. THE CURTAIN AIR BAGS MAY HAVE BEEN MIS-ASSEMBLED DURING THE MANUFACTURING PROCESS. THIS MAY CAUSE AN AIR BAG TO NOT DEPLOY OR NOT DEPLOY AS INTENDED.

  Risk: IF THE CURTAIN AIR BAG DOES NOT PERFORM AS INTENDED IN THE EVENT OF A VEHICLE CRASH NECESSITATING DEPLOYMENT OF THAT AIR BAG, IT MAY NOT PROPERLY PROTECT THE OCCUPANT, INCREASING THE RISK OF INJURIES.

  Remedy: DEALERS WILL INSPECT THE LEFT AND RIGHT CURTAIN AIR BAG ASSEMBLY AND ADJUST IF NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 9, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.

• FUEL SYSTEM, OTHER#09V477000December 15, 2009

  VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE FUEL LINE RAIL COVER THAT PROTECTS THE FUEL LINES UNDER THE VEHICLE MAY NOT BE PROPERLY ATTACHED EXPOSING THE FUEL LINES TO DAMAGE.

  Risk: DAMAGE TO THE FUEL LINES MAY RESULT IN A FUEL LEAK WHICH, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

  Remedy: DEALERS WILL INSPECT THE FUEL LINE RAIL COVER FOR PROPER ATTACHMENT AND REATTACH IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 28, 2009. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

• STRUCTURE:BODY:ROOF AND PILLARS#09V463000December 1, 2009

  VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES BUILT WITHOUT THE PANORAMIC ROOF AND DELIVERED TO PUERTO RICO FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT."

  Risk: IN THE EVENT OF A CRASH THE FRONT SEAT OCCUPANTS MAY NOT HAVE PROPER PROTECTION.

  Remedy: THESE FOUR VEHICLES ARE IN THE POSSESSION OF DEALERS IN PUERTO RICO AND DEALERS WILL REPLACE THE HEADLINER IN THE VEHICLE PRIOR TO SALE.

• SEATS#09V445000November 18, 2009

  VOLVO IS RECALLING MODEL YEAR 2010 XC60 VEHICLES. THE DRIVER'S SEAT SIDE COVER PANEL (SEAT CONTROL PANEL) IN CERTAIN DRIVER'S SIDE IMPACTS MAY RELEASE THE ATTACHMENT OF THE SEATBELT TO THE SEAT FRAME.

  Risk: SHOULD THIS CONDITION OCCUR IN A CRASH THE SEATBELT MAY FAIL TO PROPERLY RESTRAIN THE OCCUPANT INCREASING THE RISK OF INJURY.

  Remedy: DEALERS WILL MODIFY THE INSIDE OF THE DRIVER'S SEAT SIDE COVER PANEL FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 22, 2009. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.

• ELECTRICAL SYSTEM:SOFTWARE#09V343000September 1, 2009

  VOLVO IS RECALLING MY 2008-2010 S80, MODEL YEAR 2009-2010 XC70 AND MODEL YEAR 2010 XC60 VEHICLES. UNDER CERTAIN CONDITIONS THE SOFTWARE WITHIN THE CENTRAL ELECTRONIC MODULE (CEM) MAY NOT SEND A SIGNAL TO THE FUEL PUMP ELECTRONIC MODULE (PEM). THIS MISSING SIGNAL TO THE PEM INHIBITS THE START OF THE FUEL PUMP. THE DRIVER MAY BE ABLE TO START THE ENGINE IN SPITE OF THE FUEL PUMP NOT BEING ACTIVATED DUE TO RESIDUAL PRESSURE IN THE FUEL SYSTEM. IN SOME CASES, THE DRIVER MAY BE ABLE TO DRIVE THE VEHICLE A SHORT DISTANCE AT IDLE BUT THEN THE ENGINE MAY STALL.

  Risk: IF THE VEHICLE STALLS IN CERTAIN CONDITIONS, A CRASH COULD OCCUR.

  Remedy: DEALERS WILL DOWNLOAD SOFTWARE TO THE VEHICLES' CEM FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 30, 2009. VEHICLES IN DEALER'S INVENTORY WILL BE REPAIRED PRIOR TO DELIVERY. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.