RECALLS — MAKE · MODEL · YEAR
2010 Utilimaster Aeromaster recalls
4 safety recall campaigns have been filed for the 2010 Utilimaster Aeromaster with Transport Canada and the U.S. NHTSA. Here is what both agencies say.
- Canadian recalls
- 01
- U.S. recalls
- 03
- Total campaigns
- 04
Transport Canada recalls
01- Electrical#2014128
3,200 units affected
On certain vehicles, the fastener on the power stud for the electrical junction box may be loose. This could cause high heat or arcing on the terminal which could increase the risk of a fire, potentially causing injury and/or property damage. Correction: Dealers will inspect and if necessary tighten the electrical connection.
Canadian data updated August 24, 2026
U.S. NHTSA recalls
03- SEAT BELTS:FRONT:RETRACTOR#18V377000
Spartan Motors USA (Spartan) is recalling certain 1991-2018 Utilimaster Aeromaster and Walk-In Vans. These vehicles were manufactured with front seat belts that do not have an emergency locking seat belt retractor or automatic locking seat belt retractor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Risk: Without retractors, the seat belts may not accommodate different size occupants, therefore the occupants may not be properly restrained in the event of a crash, increasing the risk of injury.
Remedy: Spartan will notify owners and will install seat belts with retractors, free of charge. The recall began on August 6, 2018. Owners may contact Spartan customer service at 1-800-582-3454. Spartan's number for this recall is 18019.
- ELECTRICAL SYSTEM#14V187000
Spartan Motors, Inc. (Spartan) is recalling certain model year 2010-2014 Utilimaster Aeromaster walk-in vans manufactured January 1, 2010, through March 19, 2014. The affected vehicles may have a loose power connection at the power stud terminal block.
Risk: A loose power stud may cause arcing or high heat on the terminal, increasing the risk of a fire.
Remedy: Spartan will notify owners, and dealers will inspect and properly tighten the electrical connection, as necessary, free of charge. The recall began on May 23, 2014. Owners may contact Spartan at 1-517-543-6400.
- STRUCTURE:BODY:DOOR#11V606000
Certain Utilimaster model year 2009 through 2011 Aeromaster and one model year 2011 Reach work trucks manufactured from September 1, 2009, through December 22, 2011, fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 206, "Door Locks and Door Retention Components."
Risk: Certain work trucks are not equipped with either a primary door latch system or a door latch system with a fully latched position and a door closure warning system as required by FMVSS 206. Without a door closure warning system, the driver may not be aware that the door is not fully latched. The door could partially open without warning and the driver may be at an increased risk of injuries in the event of a crash.
Remedy: Utilimaster will notify owners, and dealers will repair the vehicles free of charge. The safety recall began on November 16, 2012. Owners may contact Utilimaster at 1-800-582-3454.
Does this recall apply to my vehicle?
Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.
What to do
Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, or to book the work, contact your manufacturer or dealer with your full VIN, or use the official channel:
- NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
- Defects and recalls database — Transport Canada
Check a 2010 Utilimaster Aeromaster VIN
A VIN decode confirms your vehicle's exact model year, trim and assembly plant, then runs this same recall check against it.