2020 Toyota Tundra recalls

• Electrical#2021723November 24, 2021

  55,683 units affected

  Issue: This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. Note: This recall only affects the following block heater/cord part numbers: C014003034 PK5A408J09 PU14000904 C014003151 PK5A408J13 PU14000905 C014000885 PK5A489J11 PU14000907 C014000888 PK5A489J22 PU14000909 C014000907 PK5A410H00 PU14000911 C014100904 PU14000900 PU14000913 C014100907 PU14000901 PU14003571 C014100911 PU14000902 PK5A489J14 PK5A408J05 PU14000903 Safety Risk: Engine block heater wiring that overheats or melts could create the risk of a fire. Corrective Actions: Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.

• Lights And Instruments#2021544September 2, 2021

  6,380 units affected

  Issue: On certain trucks equipped with halogen headlamps, when the high beams are switched on, both the high and low beam lights turn on. Under certain conditions, this could cause the headlamps and wiring to overheat. Safety Risk: A headlamp that overheats can cause a loss of lighting and could create a fire risk. Corrective Actions: Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to modify the engine wire harness assembly. The dealer will also inspect the headlamp assemblies, bulbs and bulb connectors for damage. The dealer will replace parts damaged by this problem.

• Lights And Instruments#2020321July 15, 2020

  23,080 units affected

  Issue: On certain vehicles, the wire harness for the front turn signal lights was assembled incorrectly. As a result, the turn signals and hazard warning lights are not bright enough to meet Canadian regulations. This could cause other road users not to notice when the signal or hazard warning lights are turned on. Safety Risk: Signal lights that are not bright enough could make the vehicle less visible to others, and could increase the risk of a crash. Corrective Actions: Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to modify the wire harness for the front turn signal lights.

• Label#2019651December 20, 2019

  178 units affected

  Issue: On certain vehicles, the spare tire size is listed as P275/65R18, whereas the actual installed spare tire size is P255/70R18. Canadian regulations require companies correct tire information on the tire information label. Safety Risk: This small error is unlikely to affect safety. Corrective Action: This is not a recall. This notice is for information only. The company has made changes to correct this label on all new vehicles.

Canadian data updated August 24, 2026

• STEERING:HYDRAULIC POWER ASSIST SYSTEM#21E103000December 23, 2021

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain JTEKT power steering gear assembly service parts for 2007-2021 Tundra and 2008-2022 Sequoia, part numbers 44250-0C160, 44250-0C131, 44250-0C170, and 11250-0C121. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

  Risk: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

  Remedy: Dealers will inspect and replace the power steering gear assembly, free of charge. Owner notification letters were mailed on February 17, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 21TH01.

• STEERING:HYDRAULIC POWER ASSIST SYSTEM#21V920000November 23, 2021

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2008-2022 Sequoia and 2007-2021 Tundra vehicles. The power steering gear assembly may have been manufactured incorrectly, which can result in an oil leak.

  Risk: An oil leak may cause a sudden loss of power steering assist, increasing the risk of a crash.

  Remedy: Dealers will inspect and replace the power steering gear assembly as necessary, free of charge. Owner notification letters were mailed on January 21, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB10 and 21TA10.

• EXTERIOR LIGHTING:HEADLIGHTS#21V688000September 2, 2021

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2021 Tundra vehicles. The headlight electrical circuits may power the high and low beams simultaneously, which could overheat the electrical connector.

  Risk: An overheated electrical connector can increase the risk of a fire.

  Remedy: Dealers will modify the engine wire harness assembly and replace any damaged bulb, bulb connector, and/or headlight assembly as necessary, free of charge. Owner notification letters were mailed April 25, 2022. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are 21TB06 and 21TA06.

• FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP#20V682000November 4, 2020

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2019 4Runner, 2019-2020 Avalon, 2019 Corolla Hatchback, 2017-2019 Highlander, 2018-2020 Camry, 2020 Corolla, 2018-2019 Land Cruiser, 2017-2020 Tacoma, 2019-2020 RAV4, 2019-2020 Sequoia, 2017-2020 Sienna, 2019-2020 Tundra, 2018-2020 Lexus ES350, 2017 Lexus GS200t, 2017-2019 Lexus GS350, 2019 Lexus GS300, 2018-2020 Lexus LC500h, 2019-2020 Lexus LS500, 2018-2019 Lexus GX460, 2017 Lexus IS200t, 2019 Lexus IS300, 2019 Lexus IS350, 2018-2020 Lexus LC500, 2018 Lexus LS500, 2019 Lexus LS500h, 2018-2019 Lexus LX570, 2017 Lexus RC200t, 2019 Lexus RC300, RC350, 2017 and 2019-2020 Lexus RX350, 2018-2020 RX350L, 2019 Lexus UX200, 2018-2019 Lexus NX300 vehicles. The low-pressure fuel pump inside the fuel tank may fail.

  Risk: If the fuel pump fails, the engine can stall while driving, increasing the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will replace the fuel pump assembly with an improved one, free of charge. Owners of specific models were notified that remedy parts were available starting January 21, 2021. Owners of other models will be notified as remedy parts become available. Remedy parts should be available for all affected vehicles by late March 2021. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Note: This recall is an expansion of recall 20V-012. Toyota's number for this recall is 20TA02. Lexus' number for this recall is 20LA01.

• EXTERIOR LIGHTING:TURN SIGNAL#20V410000July 15, 2020

  Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2018-2020 Toyota Tundra vehicles equipped with LED headlight assemblies. Due to a wiring error, the front turn signals may not flash brightly enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

  Risk: If the turn signals or hazard lamps do not flash brightly enough, other drivers may fail to see that the turn signal or hazard lamp functions have been activated, increasing the risk of a crash.

  Remedy: Toyota will notify owners, and dealers will modify the wire harness connected to the front turn signal bulbs free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-800-270-9371. Toyota's number for this recall is 20TB12/20TA12.