RECALLS — MAKE · MODEL · YEAR
2022 SKI-DOO Expedition recalls
4 safety recall campaigns have been filed for the 2022 SKI-DOO Expedition with Transport Canada and the U.S. NHTSA. Here is what both agencies say.
- Canadian recalls
- 04
- U.S. recalls
- 00
- Total campaigns
- 04
Transport Canada recalls
04- Fuel System#2023135
7,903 units affected
Issue: On certain snowmobiles, the retainer screw for the fuel injector hose may not have been tightened properly. As a result, fuel could leak. Note: This recall only affects snowmobiles equipped with an 850 E-TEC or 850 E-TEC Turbo engine. This recall replaces Transport Canada recall 2022-496. Snowmobiles that were repaired under that recall don't require this repair. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: BRP will notify owners by mail and instruct you to take your snowmobile to a dealership to inspect and, if necessary, install a new fuel injector hose retainer screw.
- Fuel System#2022496
3,936 units affected
This recall was replaced by Transport Canada Recall No. 2023-135. Issue: On certain snowmobiles, the retainer screw for the fuel injector hose may not have been tightened properly. As a result, fuel could leak. Note: This recall only affects snowmobiles equipped with an 850 E-TEC or 850 E-TEC Turbo engine. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: BRP will notify owners by mail and instruct you to take your snowmobile to a dealership to inspect and, if necessary, install a new fuel injector hose retainer screw.
- Fuel System#2022016
3,899 units affected
Issue: On certain snowmobiles equipped with a 900 ACE turbo engine, pressure may build-up in the fuel tank under certain riding conditions. If this happens and the snowmobile is tilted or flipped to its right side, fuel could leak from fuel tank vent onto hot engine parts. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: BRP will notify owners by mail and instruct you to take your snowmobile to a dealer to re-route and change the exit location of the fuel tank vent. The dealer will also install a protective plate over the outlet of the vent.
- Lights And Instruments#2021752
1,438 units affected
Issue: On certain snowmobiles, a software error causes the speedometer to show a vehicle speed that is half (50 %) of the true speed. Note: This recall only affects certain snowmobiles with either a 600 ACE or 900 ACE engine. Safety Risk: A speedometer that shows only half of the vehicle speed could lead you to drive too fast. This could increase the risk of a crash. Corrective Actions: BRP will notify owners by mail and instruct you to take your snowmobile to a dealer to update the engine control module (ECM).
Canadian data updated August 24, 2026
U.S. NHTSA recalls
00No recalls found for this make, model, and year.
Does this recall apply to my vehicle?
Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.
What to do
Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, or to book the work, contact your manufacturer or dealer with your full VIN, or use the official channel:
- NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
- Defects and recalls database — Transport Canada
Check a 2022 SKI-DOO Expedition VIN
A VIN decode confirms your vehicle's exact model year, trim and assembly plant, then runs this same recall check against it.