KIA Sedona recalls

• Label#2024549August 15, 2024

  647,384 units affected

  Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safety Risk: These small errors do not affect vehicle safety. Corrective Actions: This is not a recall. Kia has corrected the compliance label for all new vehicles.

• Powertrain#2022453August 10, 2022

  3,540 units affected

  Issue: On certain vehicles, a problem with the transmission shifter assembly may allow you to shift out of the Park position (P) without pressing the brake pedal. If the transmission is shifted without applying the brakes and the parking brake isn't used, the vehicle could move suddenly or roll away. Safety Risk: A vehicle that moves suddenly or that rolls away could create the risk of an injury or a crash. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealership to inspect the shift lever assembly. The shift lock lever and holder will be replaced, if necessary. To reduce the safety risk, Kia recommends that you should always use the parking brake when you park.

• Airbag#2022023January 27, 2022

  58,054 units affected

  Issue: On certain vehicles, a defect in the airbag control unit could cause the airbag warning light to turn on. If this happens, the airbag system may not work properly, and the airbags may not inflate in a crash. Safety Risk: An airbag system that does not work properly could create an increased risk of injury in a crash. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealer to update the airbag control unit software. If the airbag warning light is on because of diagnostic trouble code B1620, the dealer will replace the airbag control unit.

• Electrical#2021680November 5, 2021

  9,612 units affected

  Issue: Certain vehicles may be equipped with an accessory trailer wiring harness that could fail. Over time, water could leak into the control module and cause a short circuit. If this happens, there could be loss of the trailer lights. Note: This recall affects trailer wiring harness kits that may have been ordered at the time of a vehicle purchase, or purchased separately from a dealer as an aftermarket accessory. Safety Risk: A loss of trailer lights could make the trailer less visible. In addition, other drivers may not recognize that the vehicle ahead is braking or intends to turn. This could increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the trailer wiring harness. If the harness is from the lot (batch) affected by this problem, the dealer will replace it. Kia recommends that you should always check to ensure that trailer lights work properly before towing.

• Lights And Instruments#2021574September 17, 2021

  5,851 units affected

  Issue: On certain vehicles, an intermittent problem could cause the turn signals to activate in the opposite direction from what a driver intends. For example, when the driver uses the right turn signal, the left signal could turn on. Safety Risk: Turn signals that do not work properly may cause confusion and could increase the risk of a crash. Corrective Action: Kia will notify owners by mail and instruct you to bring your vehicle to a dealer to update the Smart Junction Box software.

• Electrical#2020318July 14, 2020

  2,369 units affected

  Issue: On certain vehicles, the nut that attaches the battery cable to the alternator may be loose. This can result in electrical arcing (sparks). Safety Risk: Electrical arcing could increase the risk of a fire. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealer to inspect, and if necessary, tighten the alternator battery (B+) terminal nut.

• Fuel System#2020075February 26, 2020

  3,086 units affected

  Issue: On certain vehicles, the fuel rail could develop small cracks. If this happens, there could be a fuel odour or fuel leak in the engine compartment. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealer to replace the fuel rail.

• Brakes#2020064February 19, 2020

  15,238 units affected

  Issue: On certain vehicles, moisture can enter the brake Hydraulic Electronic Control Unit (HECU) and cause a short circuit. Safety Risk: A short circuit could create a fire risk. This can happen even if the vehicle is parked. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealer to install a relay to power off the HECU when the vehicle is turned off. Kia recommends that you should park your vehicle outdoors, and away from other vehicles or structures until the recall repairs have been completed.

• Seats And Restraints#2019103March 1, 2019

  5,314 units affected

  Issue: On certain vehicles, the wiring for the Occupant Detection System (ODS) could break. This would cause the airbag system to not turn off the airbag when an infant or child is seated in the front passenger seat. This problem only affects vehicles with a manual front-passenger seat. Safety Risk: In a crash, an airbag that deploys in front of an infant or child increases the risk of injury. Corrective Actions: The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to remove a wiring harness clip. This will prevent the wire from breaking. If the wiring is found damaged, the dealer will replace the front passenger seat cushion. Note: If the wiring breaks, the SRS airbag warning light will come on and the "Passenger Airbag Off" indicator will not turn on.

• Airbag#2018301June 8, 2018

  65,548 units affected

  On certain gasoline and hybrid engine vehicles, the circuits within the airbag control unit may become damaged. This could cause the airbags and seat belt pretensioners to not deploy in certain collisions where deployment is warranted, which could increase the risk of injury to vehicle occupants. Correction: Dealers will install a wire harness kit between the ACU connector and vehicle harness connector as necessary. Note: This recall does not affect the 2013 model year Optima Hybrid.

• Structure#2018290June 1, 2018

  9,578 units affected

  On certain vehicles, the power sliding door control module may not be calibrated correctly. As a result, a closing door may not stop and reverse direction if blocked by an object, increasing the risk of injury to vehicle occupants. Correction: Dealers will reprogram the power sliding door control module software.

• Structure#2016274June 2, 2016

  23,397 units affected

  On certain vehicles, the secondary hood latch could corrode, and may result in the mechanical binding of the latch. This could cause the secondary hood latch to remain in the open position when the hood is closed. If the vehicle were to be driven with the primary hood latch disengaged, there is a potential that the secondary hood latch may not hold the hood closed as designed while the vehicle is in motion. If this were to occur, it could compromise the driver’s ability to see the road and its users, as well as cause damage to the windshield. These issues could result in a crash causing injury and/or property damage. Correction: Dealers will replace the secondary latch with an improved secondary latch with an enhanced corrosion coating.

• Suspension#2016273June 2, 2016

  14,091 units affected

  On certain vehicles, road salt can corrode the front control arms, which may ultimately lead to control arm failure. This could result in a loss of vehicle control, increasing the risk of a crash causing injury and/or property damage. Correction: For 2006-2007 model year vehicles, dealers will replace the front lower control arms if they were not previously replaced under recall 2013-388. For 2008-2012 model year vehicles, dealers will inspect the control arms and either apply an anticorrosion treatment or replace the control arms, as necessary. Note: This recall supersedes recall 2013-388.

• Suspension#2013388November 6, 2013

  16,432 units affected

  On certain vehicles, road salt can corrode the front control arms, which may ultimately lead to control arm failure. This could result in a loss of vehicle control, increasing the risk of a crash causing injury and/or property damage. Correction: Dealers will inspect the control arms and either apply an anticorrosion treatment or replace control arms, as necessary.

• Electrical#2013324September 25, 2013

  39,054 units affected

  On certain vehicles, the stop lamp switch may fail and cause intermittent operation of the brake lights. Failure of the brake lights to illuminate when the brake pedal is depressed could result in a crash causing property damage and/or personal injury. Correction: Dealers will replace the switch. Note: This is an expansion of recall 2013-098.

Canadian data updated August 24, 2026