2020 Keystone Cougar recalls

• Structure#2022161March 31, 2022

  32 units affected

  Issue: On certain Cougar 29FKD travel trailers, the tires could contact an outrigger while driving. This could damage the tire and cause a tire failure. Safety Risk: A tire failure could cause a loss of control and increase the risk of a crash. Corrective Actions: Keystone will notify owners by mail and instruct you to bring your travel trailer to a dealership to modify the outrigger to improve tire clearance. The dealer will add an additional outrigger between the two tires (over the center spring hanger) and inspect the tires for damage. To reduce the safety risk, Keystone recommends that you should unload all cargo and empty the holding tanks (fresh water, grey water, black water, and water heater) and take your trailer to a dealership for repair.

• Accessories#2021569September 16, 2021

  11,967 units affected

  Issue: On certain RV trailers, the propane (LP) regulator could fail. If this happens, high-pressure propane could reach the appliances. Note: This recall only affects trailers equipped with a Winntec model 6020 propane regulator. Safety Risk: Unregulated propane pressure can create the risk of an appliance fire. Corrective Action: Keystone will notify owners by mail and instruct you to take your travel trailer to a dealer to replace the propane (LP) regulator.

• Structure#2021317May 25, 2021

  150 units affected

  Issue: On certain RV trailers, the frame rail could bend or break. If this happens, there could be a sudden change in vehicle handling. Safety Risk: A sudden change in vehicle handling could increase the risk of a crash. Corrective Actions: Keystone RV will contact owners by mail and instruct you to bring your RV trailer to a dealer to add cross-braces and an outrigger to support the frame.

• Electrical#2020526November 4, 2020

  146 units affected

  Issue: On certain travel trailers, the power inverter may have been wired incorrectly. As a result, the shore power cord may be back-fed with electricity when the inverter is turned on. Safety Risk: A power cord that is back-fed with electricity could create a risk of electrocution. Corrective Actions: Keystone will notify owners by mail and instruct you to take your vehicle to a dealer to test the function of the inverter. Dealers will rewire the inverter, as needed. Keystone recommends that if the inverter is turned on and any circuits other than the "Off The Grid Inverter Outlet" circuit is powered on, to turn off the inverter and have it inspected.

• Accessories#2020315July 13, 2020

  696 units affected

  Issue: On certain fifth-wheel trailers, the upper part of the TV antenna could detach from the trailer. Safety Risk: An antenna that detaches from the trailer could create a road hazard for others and increase the risk of a crash. Corrective Actions: Keystone RV will notify owners by mail and instruct you to take your trailer to a dealer to replace the TV antenna.

• Accessories#2020243June 1, 2020

  35 units affected

  Issue: On certain travel trailers, the interior cooktop burner could be affected by the operation of the furnace. This could potentially cause the burner flame to invert. Safety Risk: An inverted burner flame could create the risk of a burn injury or cause a fire. Corrective Actions: Keystone will notify owners by mail and instruct you to take your trailer to a dealer to inspect the operation of the interior range cooktop with the furnace running. Any units affected by this problem will be repaired. To minimize the safety risk, Keystone recommends that the furnace and the range cook top should not be used at the same time before the recall repairs have been completed.

• Lights And Instruments#2019493October 4, 2019

  12 units affected

  Issue: On certain RV trailers, the wiring for the Solar Prep system may not be properly connected to a circuit breaker. As a result, there may be no protection against an electrical overload or short circuit. Safety Risk: An electrical overload or short circuit on an unprotected circuit could create an increased risk of a fire. Corrective Actions: The company will notify owners by mail and instruct them to take their trailer to a dealer to inspect the wiring for the Solar Prep system. If it is not connected correctly to a circuit breaker, the wiring will be modified.

Canadian data updated August 24, 2026

• STRUCTURE:FRAME AND MEMBERS#22V209000March 31, 2022

  Keystone RV Company (Keystone) is recalling certain 2019-2022 Cougar 29FKD travel trailers. Improper clearance may allow the tires to contact the outrigger, causing damage to the tires.

  Risk: Damaged tires can fail, causing a loss of vehicle control and increasing the risk of a crash.

  Remedy: Dealers will notch the existing outrigger and install an additional outrigger between the two tires to provide proper clearance, free of charge. Owner notification letters were mailed May 12, 2022. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 22-430.

• EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS#21V708000September 13, 2021

  Keystone RV Company (Keystone) is recalling certain 2019-2021 Dutchmen Aspen Trail, Coleman, Keystone Cougar, Bullet, Passport, Hideout, Springdale, Sprinter, 2019 Keystone Impact, Fuzion, Residence, Retreat, Summerland, and Dutchmen Kodiak recreational vehicles, equipped with Winntec model 6020 two-stage propane regulators. The regulator may fail, causing an increase in propane pressure.

  Risk: Increased propane pressure can enlarge the flames in gas appliances, increasing the risk of a fire.

  Remedy: Dealers will replace the regulator and test the propane system for leaks, free of charge. Owner notification letters mailed February 25, 2021. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 21-414.

• STRUCTURE:FRAME AND MEMBERS#21V380000May 24, 2021

  Keystone RV Company (Keystone) is recalling certain 2017-2021 Keystone Cougar 368MBI trailers. The frame rails do not have enough cross support, which could cause them to buckle under certain side-load stress conditions.

  Risk: A buckled frame rail can increase the risk of a crash.

  Remedy: Dealers will add cross braces between each spring hanger and an outrigger between the tires on the off-door side of the vehicle, free of charge. Owner notification letters were mailed July 15, 2021. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 21-411.

• EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:120/240 VAC ELECTRICAL SYSTEM:INVERTER#20V670000October 30, 2020

  Keystone RV Company (Keystone) is recalling certain 2020-2021 Cougar trailers equipped with the Off the Grid (OTG) Solar package. The inverter may have been incorrectly wired, causing power to energize the shore power connection, when in use.

  Risk: If the inverter is turned on, and energizes the shore power connection, it can increase the risk of injury.

  Remedy: Keystone will notify owners, and dealers will test the function of the inverter and rewire it as needed, free of charge. The recall began November, 18, 2020. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 20-389.

• EQUIPMENT:ELECTRICAL#20V398000July 7, 2020

  Keystone RV Company (Keystone) is recalling certain 2019-2020 Keystone Carbon, Cougar, Fuzion, Impact and Raptor fifth-wheel trailers equipped with a Furrion over the air (OTA) wing-style television antenna. The antenna may separate from the mounting base during transit, becoming a road hazard.

  Risk: If the antenna detaches from the trailer while moving it may become a road hazard, increasing the risk of a crash.

  Remedy: Keystone will notify owners, and dealers will replace the Furrion wing-style antenna with a Winegard dome-style antenna, free of charge. The recall began August 27, 2020. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 20-381.

• EQUIPMENT:RECREATIONAL VEHICLE/TRAILER#20V302000May 26, 2020

  Keystone RV Company (Keystone) is recalling certain 2020-2021 Cougar travel trailers, model 24RDS, equipped with a Furrion range cook top. The interior range cooktop is installed in a cabinet that may not be entirely sealed from the furnace cavity. As a result, during furnace operation, the interior range cooktop burner flame may invert.

  Risk: If the cooktop burner flames invert, there is an increased risk of a fire and injury.

  Remedy: Keystone will notify owners, and dealers will inspect the interior range cooktop with the furnace running, installing a plywood panel to seal it as necessary, free of charge. This recall began July 17, 2020. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 20-377.

• ELECTRICAL SYSTEM:WIRING#19V689000September 30, 2019

  Keystone RV Company (Keystone) is recalling certain 2020 Cougar fifth wheels and travel trailers, models 22RBS, 23MLS, 25RES, 26RBS, 26RKS, 27RES, 27SAB, 27SGS, 29BHS, 29FKD, 29RLD, 30RKD, 31MBS, 32RDB, 32RLI and 34TSB. The wiring for the solar preparation kit may have been incorrectly wired to the wrong side of the 12V breaker, potentially allowing an electrical short circuit in the event of damage to the wiring.

  Risk: An electrical short circuit increases the risk of a fire.

  Remedy: Keystone will notify owners, and dealers will inspect and correct the installation of the solar preparation wiring, as necessary, free of charge. The recall began on October 25, 2019. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 19-361.

• EQUIPMENT:OTHER:LABELS#19V650000September 11, 2019

  Keystone RV Company (Keystone) is recalling certain 2020 Cougar 30RKD trailers. The 60"x29" emergency exit windows over the dinette table in the cabin are missing a red handle and "EXIT" label.

  Risk: If an emergency event occurs, trailer occupants may not be aware of the emergency exit function of the window, increasing the risk of an injury.

  Remedy: Keystone will notify owners, and dealers will replace the existing black exit handles with red handles and add an "EXIT" label, free of charge. The recall began October 9, 2019. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 19-360.