RECALLS — MAKE · MODEL · YEAR
2014 Kalmar Ottawa recalls
12 safety recall campaigns have been filed for the 2014 Kalmar Ottawa with Transport Canada and the U.S. NHTSA. Here is what both agencies say.
- Canadian recalls
- 04
- U.S. recalls
- 08
- Total campaigns
- 12
Transport Canada recalls
04- Electrical#2017170
59 units affected
On certain vehicles, the chassis power distribution center may not have been sealed properly. This could result in moisture ingress, which could lead to an electrical short and fire, increasing the risk of injury and/or damage to property. Correction: Dealers will replace the chassis power distribution center with a design using sealed modules to eliminate exposure to moisture and improved abrasion resistance. Note: This recall supersedes recall 2016-345. Vehicles repaired under the previous recall will require re-inspection and repair.
- Electrical#2017169
55 units affected
On certain vehicles, the ground trace in the cab power distribution center circuit board may not adequately carry the required maximum electrical load demands of the circuit. Failure of the ground trace could result a possible fire, which would increase the risk of injury and/or damage to property. Correction: Dealers will relocate the ground path from the circuit board directly to the cab ground stud.
- Electrical#2015146
14 units affected
On certain vehicles, movement of the primary battery ground cable could be restricted. This could cause the eyelet on the cable to fail due to fatigue. If this were to happen, the engine crank circuit could find an alternative path to ground through the engine harness. The ground wire in the harness would not be able to carry the amperage associated with the cranking circuit, and the insulation on the engine harness ground wire could melt, which could result in a fire causing injury and/or damage to property. Correction: Dealers will replace and reroute the battery ground cable.
- Fuel System#2014400
4 units affected
On certain vehicles equipped with Cummins ISB or ISL engines, the fuel filter shell and nut plate could separate, causing a fuel leak and also causing the engine to stall. Stalling would result in a loss of motive power, increasing the risk of a crash resulting in injury and/or damage to property. Correction: Cummins-authorized dealers will replace the fuel filter.
Canadian data updated August 24, 2026
U.S. NHTSA recalls
08- ELECTRICAL SYSTEM#16V951000
Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2014-2016 Ottawa T2 vehicles manufactured August 16, 2014, to November 17, 2016. The affected vehicles are equipped with a chassis power board that is not protected from moisture.
Risk: Exposure to moisture may result in an electrical short which can increase the risk of a fire.
Remedy: Kalmar will notify owners, and dealers will replace the chassis power distribution center with sealed modules, free of charge. Kalmar issued an interim notification to owners on February 7, 2017. Owners may contact Kalmar customer service at 1-785-229-6341. Note: The remedy for this recall will also remedy the safety issue addressed by recall 16V-073, therefore that recall will be superseded by this one. The recall began on March 3, 2017. Any vehicle that was remedied under that campaign still needs this recall remedy.
- ELECTRICAL SYSTEM:WIRING#16V850000
Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2014-2016 Ottawa T2 vehicles manufactured July 15, 2014, to November 3, 2016. In the affected vehicles, the ground circuit of the cab power distribution circuit board can be overloaded.
Risk: An overloaded ground circuit may increase the risk of a fire in the dashboard.
Remedy: Kalmar will notify owners, and dealers will modify the wiring harness on the electrical option circuit to bypass the undersized ground circuit, free of charge. The recall began on January 17, 2017. Owners may contact Kalmar customer service at 1-785-229-6327.
- SERVICE BRAKES, AIR#16V189000
Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2014-2016 Ottawa T2 vehicles manufactured July 14, 2014, to March 25, 2016. The brake system air pressure gauge, may not display the accurate air pressure level. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems."
Risk: If the brake system pressure gauge does not display the proper air pressure, there is an increased risk of a crash.
Remedy: Kalmar will notify owners, and dealers will replace the air system pressure sensors, free of charge. The recall began on June 3, 2016. Owners may contact Kalmar customer service at 1-785-229-6327.
- ELECTRICAL SYSTEM#16V073000
Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2014-2016 Ottawa T2 trucks manufactured July 14, 2014, to November 2, 2015. The affected vehicles are equipped with a chassis power board that is not protected from moisture. Additionally, the bolts that mount the chassis power board may rub against the circuit board and cause an electrical short.
Risk: Exposure to moisture or rubbing from mounting bolts may result in an electrical short which can increase the risk of a fire.
Remedy: Kalmar will install nylon washers to any truck that were not built with washers. The recall began on April 21, 2016. Owners may contact Kalmar customer service at 1-785-229-6341.
- ENGINE AND ENGINE COOLING:ENGINE#15V357000
Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2010-2014 Ottawa tractors manufactured December 6, 2010, to July 21, 2014, equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
Risk: If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Remedy: Cummins will notify owners on behalf of Kalmar, and dealers will secure the ends of the 90-degree elbow. In addition, the electronic control module (ECM) will be reprogrammed with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 12, 2015. Owners may contact Kalmar customer service at 1-785-229-6327 or Cummins customer service at 1-800-343-7357.
- SERVICE BRAKES, AIR:ANTILOCK#15V177000
Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2014-2015 Kalmar Ottawa T2 terminal tractors manufactured September 15, 2014, to February 10, 2015. The affected vehicles have the wiring for the rear axle antilock brake system (ABS) components wired incorrectly. Specifically, the left side components are connected to the right side of the ABS control module and vice versa.
Risk: If the communication between the ABS components and the module is reversed, it can cause vehicle instability during braking, increasing the risk of a vehicle crash.
Remedy: Kalmar will notify owners, and dealers will correct the ABS wiring, free of charge. The recall is expected to begin April 27, 2015. Owners may contact Kalmar customer service at 1-785-229-6327.
- ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES#15V140000
Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2014-2015 Ottawa terminal tractors manufactured June 20, 2014, to November 14, 2014. Due to improper routing, the battery ground cable may detach from its mounting on the transmission, and as a result, excessive current may travel through the vehicle's engine harness, melting it.
Risk: Melting of the engine harness may cause an electrical short and increase the risk of a fire.
Remedy: Kalmar will notify owners, and dealers will replace the battery cable and correct its routing to eliminate stress on its attachment point, free of charge. The recall began on March 26, 2015. Owners may contact Kalmar customer service at 1-785-229-6327.
- FUEL SYSTEM, DIESEL#14V579000
Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2014 Ottawa terminal tractors manufactured June 2, 2014, to July 31, 2014. The Cummins ISB or ISL engines in these vehicles may have been equipped with Fleetguard UFF-XT fuel filters, part number FF63009, whose filter shell may separate from the fuel filter nut plate causing the engine to stall without warning.
Risk: If the engine stalls unexpectedly there is an increased risk of a crash.
Remedy: Kalmar will notify owners, and Cummins service centers will replace the fuel filter with a non-defective one, free of charge. Kalmar issued an interim notification to owners on November 10, 2014. The recall is expected to begin in November 2014. Owners may contact Kalmar customer service at 1-785-229-6327. Kalmar's number for this recall is C1545. Owners may also contact Cummins customer service at 1-800-223-4583.
Does this recall apply to my vehicle?
Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.
What to do
Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, or to book the work, contact your manufacturer or dealer with your full VIN, or use the official channel:
- NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
- Defects and recalls database — Transport Canada
Check a 2014 Kalmar Ottawa VIN
A VIN decode confirms your vehicle's exact model year, trim and assembly plant, then runs this same recall check against it.