2020 Jeep Wrangler recalls

• Structure#2023165March 23, 2023

  3,309 units affected

  Issue: The frame on certain vehicles may have been built with an extra and unused mounting stud near the fuel tank. As a result, the stud could contact the fuel tank in a crash and create a fuel leak. Note: This recall only affects two-door models. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealership to inspect and, if necessary, remove the stud.

• Powertrain#2023089February 23, 2023

  7,464 units affected

  Issue: Under certain conditions, the clutch pressure plate could overheat and break. If this happens, the pressure plate may also crack or break the transmission case. This could cause debris to fall from the vehicle. Note: This recall only affects certain vehicles equipped with a 3.6 L engine and a manual transmission. Vehicles repaired under FCA Canada recalls Y01, Y03 and Y07 (Transport Canada recall 2021-035) also require this repair. Safety Risk: Debris from an overheated and fractured pressure plate could contact nearby parts and increase the risk of a fire. Parts that fall from the vehicle could create a road hazard for others and increase the risk of injury. Corrective Actions: FCA Canada will notify owners by mail and advise you to tale your vehicle to a dealership to replace the clutch assembly. The dealer will also inspect and, if necessary, update the instrument panel cluster and powertrain control module software.

• Engine#2022584October 14, 2022

  6,861 units affected

  Issue: On certain vehicles equipped with a 3.0 L diesel engine, the high-pressure fuel pump could fail. If this happens, you may notice a change in engine performance, a fuel leak, or a malfunction indicator lamp and/or service electronic throttle control tell-tale may turn on. This could also result in a sudden loss of engine power while driving. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealership to replace the high-pressure fuel pump. Additional fuel system parts may be replaced, if necessary.

• Visual System#2022476August 25, 2022

  290 units affected

  Issue: On certain vehicles equipped with a 3.0 L diesel engine, a software problem could cause the radio to reset. If you shift to reverse while the computer is resetting, the rearview camera image will not appear on the display. Canadian regulations require the rearview image to display when the transmission is shifted into reverse gear. Safety Risk: A rearview camera image that is slow to appear could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealership to update the radio software.

• Fuel System#2021530August 26, 2021

  1,377 units affected

  Issue: On certain vehicles, the connector on the high pressure fuel line in the engine compartment could crack and create a fuel leak. Note: This recall only affects vehicles equipped with a 2.0 L engine. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the fuel supply line. It will be replaced, if required.

• Powertrain#2021035January 28, 2021

  4,349 units affected

  Issue: In certain circumstances, the clutch pressure plate could overheat and break. If this happens, the pressure plate may also crack or break the transmission case. This could cause debris to fall from the vehicle. Note: This recall only affects certain vehicles equipped with a 3.6 L engine and a manual transmission. Safety Risk: Debris from an overheated and fractured pressure plate could contact nearby parts and increase the risk of a fire. Parts that fall from the vehicle could create a road hazard for others, and increase the risk of injury. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to update vehicle software. This update will reduce the engine power if the clutch overheats.

• Visual System#2020145April 6, 2020

  46,772 units affected

  Issue: On certain vehicles, the rearview camera image may be displayed even after the transmission is shifted out of reverse. This could cause a possible distraction for the driver. Canadian regulations require the rearview image to turn off within 10 seconds after shifting from reverse gear. Safety Risk: A driver that is distracted could have an increased risk of a crash. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to update the radio software.

• Powertrain#2020083March 3, 2020

  3,513 units affected

  Issue: On certain vehicles equipped with a manual transmission, the clutch pressure plate could overheat and break. If this happens, there would be a loss of power to the wheels. A broken pressure plate may also crack or break the transmission case. This could cause debris to fall from the vehicle. Safety Risk: A sudden of loss power to the wheels could increase the risk of a crash. Additionally, debris from an overheated and fractured pressure plate could contact nearby parts and increase the risk of a fire. Parts that fall from the vehicle could create a road hazard for others, and increase the risk of injury. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the clutch system, install a protective hose sleeve, reroute a wire harness, and replace components as necessary

• Steering#2020024January 24, 2020

  349 units affected

  Issue: On certain vehicles, the left side lower control arm bracket may be incorrectly welded to the front axle. As a result, the lower control arm and bracket could separate. This could cause a loss of steering control. Safety Risk: A loss of steering control could create the risk of a crash. A lower control arm that detaches from the vehicle could also create a road hazard for others. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the front axle. It will be replaced if necessary.

Canadian data updated August 24, 2026

• ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY#25V741000October 30, 2025

  Chrysler (FCA US, LLC) is recalling certain 2020-2025 Jeep Wrangler 4Xe and 2022-2026 Grand Cherokee 4Xe vehicles. The high voltage battery may fail internally and lead to a vehicle fire while parked or driving.

  Risk: A vehicle fire can increase the risk of injury.

  Remedy: Owners are advised to park outside and away from structures and not to charge their vehicles until the remedy is completed. Dealers will update the high voltage battery software, and replace the high voltage battery, as necessary, free of charge. Some owner notification letters were mailed beginning December 17, 2025. The remaining owner notification letters will be mailed at a later date. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 68C. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning November 6, 2025. Vehicles that were previously recalled for the same issue under NHTSA Recalls 24V720 and 23V787 will need to have the new remedy performed.

• BACK OVER PREVENTION: SENSING SYSTEM: CAMERA#24V676000September 12, 2024

  Chrysler (FCA US, LLC) is recalling certain 2018-2024 Jeep Wrangler vehicles. The wiring harness for the rearview camera and the center brake light may short circuit, which can disable the rearview camera image and center brake light. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 111, "Rear Visibility" and 108, "Lamps, Reflective Devices, and Associated Equipment."

  Risk: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash. Additionally, a center brake light that fails to illuminate can fail to indicate to other drivers that the vehicle is slowing down, increasing the risk of a crash.

  Remedy: Dealers replaced the harness for the center brake light and rearview camera and/or the spare tire carrier/harness assembly, as necessary, free of charge. All vehicles were repaired by January 15, 2024. Owner notification letters were mailed September 26, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 77B.

• ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL#24V652000September 5, 2024

  Chrysler (FCA US, LLC) is recalling certain 2020-2024 Jeep Gladiator and 2018-2024 Jeep Wrangler vehicles. The instrument panel cluster may experience an internal short circuit and fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 101, "Controls and Displays."

  Risk: An instrument panel that fails to display critical safety information, such as the speedometer or warning lights, can increase the risk of a crash.

  Remedy: Dealers will replace the instrument panel cluster, free of charge. Owner notification letters were mailed between October 3, 2024, and January 23, 2025. Owners may contact FCA customer service at 1-800-853-1403. FCA's number for this recall is 30B.

• STRUCTURE:FRAME AND MEMBERS#23V191000March 23, 2023

  Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler vehicles. A stud on the frame assembly may puncture the fuel tank in a crash, which can result in a fuel leak.

  Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

  Remedy: Dealers will inspect and, if necessary, remove the frame stud and apply paint, free of charge. Owner notification letters were mailed April 6, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 28A.

• POWER TRAIN:CLUTCH ASSEMBLY#23V116000February 23, 2023

  Chrysler (FCA US, LLC) is recalling certain 2018-2023 Jeep Wrangler, and 2020-2023 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.

  Risk: Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.

  Remedy: Dealers will replace the clutch assembly and update the software, free of charge. Owner notification letters were mailed from November 16, 2023 through July 25, 2024. Owners may contact (FCA US, LLC) customer service at 1-800-853-1403. FCA US LLC's number for this recall is 19A. This recall expands and replaces previous recall 21V-028. Vehicles previously repaired under recall 21V-028 will need to have the new remedy completed.

• FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP#22V767000October 13, 2022

  Chrysler (FCA US, LLC) is recalling certain 2020-2022 Jeep Wrangler, Ram 1500, and 2021-2022 Jeep Gladiator vehicles equipped with 3.0L diesel engines. The high pressure fuel pump (HPFP) may fail, causing an engine stall.

  Risk: An engine stall can increase the risk of a crash.

  Remedy: Dealers will replace the HPFP and inspect and replace additional fuel system components, as necessary, free of charge. Owner notification letters were mailed October 17, 2023. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is Z96.

• BACK OVER PREVENTION:DISPLAY FUNCTION#22V638000August 25, 2022

  Chrysler (FCA US, LLC) is recalling certain 2020-2021 Jeep Wrangler, RAM 1500 and 2021 Jeep Gladiator vehicles. A radio software error may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

  Risk: A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.

  Remedy: Dealers will update the radio software, free of charge. Owner notification letters were mailed October 6, 2022. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA, LLC's number for this recall is Z86.

• FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS#21V665000August 26, 2021

  Chrysler (FCA US, LLC) is recalling certain 2020 Jeep Wrangler vehicles equipped with the 2.0 Liter engine. A cracked fuel supply line connector may leak fuel into the engine compartment.

  Risk: A fuel leak in the presence of an ignition source increases the risk of fire.

  Remedy: Dealers will inspect and replace the fuel supply line as needed, free of charge. Owner notification letters were mailed on September 10, 2021. Owners may contact FCA US LLC customer service at 1-800-853-140. FCA US LLC's number for this recall is Y10.

• POWER TRAIN:CLUTCH ASSEMBLY#21V028000January 28, 2021

  Chrysler (FCA US, LLC) is recalling certain 2018-2021 Jeep Wrangler and 2020-2021 Jeep Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.

  Risk: Overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.

  Remedy: FCA US LLC will notify owners, and dealers will add software to reduce engine torque capability when clutch assembly temperatures rise to a level that may damage the inner pressure plate, free of charge." FCA has ordered a stop sale for the affected vehicles as of February 25, 2021. Owner notification letters were mailed on March 4, 2021.

• BACK OVER PREVENTION: SENSING SYSTEM: CAMERA#20V191000September 10, 2020

  Chrysler (FCA US LLC) is recalling certain 2020 Jeep Gladiator and Jeep Cherokee, 2019-2020 Ram 1500 Pickup, Ram 2500 Pickup, Ram 3500 Pickup, Chrysler Pacifica, Dodge Durango, Jeep Grand Cherokee, Jeep Wrangler, and Jeep Renegade and 2019 Dodge Challenger vehicles equipped with 8.4" or 12" radio displays. A software error can cause the rearview camera image to remain displayed after the vehicle has been shifted out of reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

  Risk: The lingering rearview image can distract the driver, increasing the risk of a crash.

  Remedy: Chrysler has notified owners, and dealers will update the radio display software, free of charge. Optionally, owners can choose to remotely update their software via an Over-The-Air (OTA) update available as of May 1, 2020. The recall began April 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W30-W37.

• POWER TRAIN:CLUTCH ASSEMBLY#20V124000March 3, 2020

  Chrysler (FCA US LLC) is recalling certain 2018-2020 Jeep Wrangler and 2020 Gladiator vehicles equipped with manual transmissions. The clutch pressure plate may overheat and fracture.

  Risk: The overheated clutch components may increase the risk of a fire. Additionally, damage to other nearby components can result in debris falling onto the road or a loss of drive, increasing the risk of a crash.

  Remedy: Chrysler will notify owners, and dealers will reroute a wire harness and inspect the clutch system, and replace components as needed. The recall began April 30, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W12.

• SUSPENSION:FRONT:CONTROL ARM:LOWER ARM#20V042000January 24, 2020

  Chrysler (FCA US LLC) is recalling certain 2020 Jeep Wrangler vehicles. The left side lower control arm bracket and weld may not be correctly positioned.

  Risk: The improper weld may allow the lower control arm to separate from the axle which can increase the risk of a crash.

  Remedy: Chrysler will notify owners, and dealers will inspect the front axles, replacing them as necessary, free of charge. The recall began February 27, 2020. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is W01.