Isuzu NQR recalls

• Electrical#2023444August 10, 2023

  659 units affected

  Issue: On certain trucks, the seal on the fuse holders for the ignition coil packs may be too small. As a result, water could leak into the fuses and cause them to corrode or fail. If this happens, the engine may not start or it could lose power suddenly while driving. Note: This problem only affects trucks with a gasoline engine. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: Isuzu will notify owners by mail and advise you to take your truck to a dealership to replace the engine ignition coil pack fuse holders.

• Seats And Restraints#2020012January 17, 2020

  101 units affected

  Issue: On certain vehicles, the seat belts may be assembled incorrectly. As a result, the seat belts may not properly lock-up in certain types of crashes. Safety Risk: A seat belt that does not work properly could increase the risk of injury in a crash. Corrective Actions: Isuzu will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the seat belt assemblies. They will be replaced as necessary.

• Wheels#2019586November 20, 2019

  451 units affected

  Issue: On certain trucks, the lug nuts on the rear-outer wheels were not properly tightened during assembly. This could cause the nuts to loosen or fall off, and could result in a wheel separating from the vehicle. Safety Risk: A wheel separation could increase the risk of a crash. A wheel that detaches from a vehicle could create a hazard for other drivers and nearby people. Corrective Actions: Isuzu will notify owners by mail and instruct you to take your truck to a dealer to inspect the rear-outer wheel lug nuts and tighten them or install new ones, as necessary.

• Lights And Instruments#2019052February 6, 2019

  22 units affected

  Issue: On certain vehicles, the odometer display may show the units of distance as miles instead of kilometers. The actual number display is in kilometers. Safety Risk: While the safety risk is minimal, Canadian regulations require that kilometers are displayed. Corrective Actions: The company will send a letter to owners. The letter will ask them to inspect the odometer. If kilometers are displayed, the customer should tell Isuzu and no other action is needed. If miles are displayed, the owner should take their vehicle to a dealer to have the instrument cluster replaced. The new odometer will be programmed to show the number of kilometers traveled.

• Suspension#2017173March 24, 2017

  4,539 units affected

  On certain vehicles, the left rear wheel bearing hub locking bolts may not have been properly torqued during assembly. This could cause the bolts to loosen and break, which could allow the wheel assembly to move outwards from the axle housing. If this occurs, the vehicle could become more difficult to control and braking distances would increase which could result in a crash causing injury and/or damage to property. Correction: Dealers will inspect and tighten the rear left wheel bearing hub locking bolts as necessary.

• Powertrain#2017088February 17, 2017

  1,308 units affected

  On certain vehicles, a burr could impede contact between the transmission mounting bracket and the chassis cross member. This could cause the fasteners to shear or break, allowing the transmission to move out of position and impair or prevent shifting, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect the bolted connection and install a shim if necessary.

• Powertrain#2013408November 18, 2013

  67 units affected

  Certain trucks equipped with an automatic transmission could experience a sudden transmission failure. This would result in a loss of vehicle propulsion which, in conjunction with traffic and road conditions, and the driver’s reactions, could increase the risk of a crash causing property damage and/or personal injury. Correction: Dealers will replace the transmission assembly. Note: This is an expansion of recall 2013-165 for vehicles not previously included in the campaign.

• Electrical#2013212June 19, 2013

  743 units affected

  On certain vehicles equipped with an oil pan heater, over time, dust, dirt and moisture may collect at the contact point between the oil pan heater cord and the extension cord. As a result, the extension cord could overheat, which may melt the oil pan heater plug and/or block heater plug (if equipped). This could result in a fire causing property damage and/or personal injury. Correction: Dealers will inspect and clean the oil pan heater plug and the engine block heater plug (if equipped). Heat damaged plugs will be replaced. In addition, dealers will replace the extension cord and advise owners to store the cord indoors when not in use.

• Powertrain#2013165May 16, 2013

  9 units affected

  Certain trucks equipped with an automatic transmission could experience a sudden transmission failure. This would result in a loss of vehicle propulsion which, in conjunction with traffic and road conditions, and the driver’s reactions, could increase the risk of a crash causing property damage and/or personal injury. Correction: Dealers will replace the transmission assembly.

• Electrical#2011321August 25, 2011

  2 units affected

  On certain vehicles, the Electronic Control Module (ECM) software may not detect a brake pedal switch failure. If the brake pedal switch malfunctions, application of the brake pedal would fail to deactivate the cruise control. The driver would, however, be able to disengage the cruise control by other means such as; pressing the cruise control main switch located on the instrument panel, shifting the transmission into neutral or another gear, lowering the speed of the vehicle by more than 48 km/h (30 mph) through braking and/or shifting gears, or by turning the engine OFF. Failure or delay in disengaging the cruise control can increase the risk of a crash causing property damage and/or personal injury. Correction: Dealers will update the ECM software.

Canadian data updated August 24, 2026