2020 International MV recalls

• Electrical#2025652November 25, 2025

  200 units affected

  Issue: On certain trucks, poor signal strength could cause the electronic control unit (ECU) to stop working or not to work properly. As a result, some safety systems may not work, including the antilock braking system, automatic traction control, electronic stability control, active cruise control and the collision mitigation system. Note: This recall is an expansion of Transport Canada recall no. 2024-655. Safety Risks: Vehicle safety systems that don't work correctly could increase the risk of a crash. Corrective Actions: International Motors will notify owners by mail and advise you to take your truck to a dealership to reprogram the ECU software.

• Brakes#2025408August 8, 2025

  3,436 units affected

  Issue: On certain vehicles, brake fluid may be present in the brake pressure switch and wire harness. As a result, the brake switch could short circuit. Note: This recall is an expansion of recall 23517 (Transport Canada recall no. 2023-321). Certain vehicles repaired under that recall require a second repair. Safety Risk: A short circuit can cause wiring to overheat and create the risk of a fire, even while the vehicle is parked and turned off. Corrective Actions: To reduce the safety risk, International Motors advises that you should park your vehicle outdoors and away from other vehicles or structures until the recall repairs have been completed. International Motors will notify owners by mail and advise you to take your vehicle to an authorized service facility to replace the brake pressure switch and wire harness.

• Brakes#2023321June 2, 2023

  3,187 units affected

  Issue: On certain vehicles with hydraulic brakes, the brake pressure switch could leak. If this happens, the brake switch could short circuit. Safety Risk: A short circuit can cause wiring to overheat and create the risk of a fire. Corrective Actions: Navistar will notify owners by mail and advise you to take your vehicle to an authorized service facility to replace the brake pressure switch. If there is brake fluid found on the brake pressure switch connector or fuse, the wire harness will also be replaced.

• Powertrain#2023091February 23, 2023

  742 units affected

  Issue: On certain trucks equipped with an automatic transmission and the auto neutral feature, when the engine RPM increases for the stationary power take off (PTO), it can overcome the parking brake if the transmission is in drive or reverse gear. As a result, the truck may move suddenly. Safety Risk: Sudden and unexpected movement of the truck could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct you to take your truck to a dealer to update the body control module (BCM) software.

• Fuel System#2021300May 19, 2021

  173 units affected

  Issue: On certain trucks, the fuel rail assembly could develop a leak. Note: This recall only affects trucks equipped with a Cummins L9 or ISX12 diesel engine. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Cummins will notify owners by mail and instruct you to take your truck to a Cummins authorized service center to inspect the fuel rail. If damage is found, the fuel rail and fuel lines will be replaced. If no damage is found, the fuel rail will be reassembled with new crush washers.

• Powertrain#2020643December 23, 2020

  3,178 units affected

  Issue: On certain trucks equipped with an automatic transmission, when the engine RPM increases for the stationary power take off (PTO), it can overcome the parking brake if the transmission is in drive or reverse gear. As a result, the truck may move suddenly. Safety Risk: Sudden and unexpected movement of the truck could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct you to take your truck to a dealer to update the engine control module software to enable the PTO neutral interlock.

• Structure#2020551November 12, 2020

  91 units affected

  Issue: On certain trucks, the welds that attach the trailer hitch may crack due to improper welding. As a result, the hitch could detach from the truck while towing a trailer. Note: This recall only affects certain trucks with trailer hitches installed by Commercial Truck Equipment. Safety Risk: A trailer that detaches from a truck could create a risk of a crash. Corrective Actions: Commercial Truck Equipment will notify owners by mail and instruct you to take your truck to a dealer to inspect the trailer hitch and repair or replace it, as necessary. You should stop using the trailer hitch until the inspection and repair have been completed.

• Fuel System#2020163April 16, 2020

  1,411 units affected

  Issue: On certain vehicles equipped with a Cummins B6.7 diesel engine, the electric fuel heater could overheat and melt. Note: This recall replaces Transport Canada recall 2019-148. Vehicles that were repaired under that recall also require this repair. Safety Risk: A fuel heater that overheats could create the risk of a fire. This could also cause the engine to stall, increasing the risk of a crash. Corrective Actions: Cummins will notify owners by mail and instruct you to take your vehicle to a Cummins authorized service center to disable the fuel heater. The fuel heater will be replaced by installing a plug in its place. Additionally, the fuse supplying electrical power to the fuel heater will be removed and a cover will also be installed over the wire harness connector.

• Powertrain#2019592November 21, 2019

  1,806 units affected

  Issue: On certain trucks equipped with an automatic transmission, when the engine RPM increases for the stationary power take off (PTO), it can overcome the parking brake if the transmission is in drive or reverse gear. As a result, the truck may move suddenly. Safety Risk: Sudden and unexpected movement of the truck could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct you to take your truck to a dealer to update the engine control module software to enable the PTO neutral interlock.

• Fuel System#2019148March 20, 2019

  1,209 units affected

  Note: This recall is replaced by recall 2020-163. <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&rn=2020163">Please click here for more information</a>. Issue: On certain vehicles equipped with a Cummins B6.7 diesel engine, the electric fuel heater could overheat and melt. Safety Risk: A fuel heater that overheats could create the risk of a fire. This could also cause the engine to stall, increasing the risk of a crash. Corrective Actions: Cummins will notify owners by mail and instruct them to take their vehicle to a Cummins service location to install a new fuel heater and correct the wiring to the fuel heater. Additionally, the fuel heater fuse will be changed to a 30 amp fuse, and the fuse size information in the owner’s manual will be updated.

Canadian data updated August 24, 2026

• SERVICE BRAKES, HYDRAULIC:FLUID#25V502000August 6, 2025

  International Motors, LLC (International) is recalling certain 2018 International 4000 Series 4300, 2017-2025 MV, 2018-2024 1300 FBC, 2018-2025 IC Bus TC, and 2024-2025 IC Bus CECB vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

  Risk: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

  Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a silicone black jumper harness, free of charge. Owner notification letters are expected to be mailed December 15, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 25509. Vehicles previously repaired under 23V397 will need to have the new remedy completed.

• SERVICE BRAKES, AIR:DISC:CALIPER#25V178000March 21, 2025

  International Motors, LLC (International) is recalling certain 2024 HV, 2020-2025 MV, and 2019 Workstar 7400 trucks. The caliper may contact a suspension spring or axle U-bolt and prevent the outer brake pad from functioning.

  Risk: A loss of outer brake pad function can extend the vehicle's stopping distance, increasing the risk of a crash.

  Remedy: Dealers will switch the left and right rear air disc brake calipers, replace the rear brake torque plates, and replace the brake pads, free of charge. Owner notification letters were mailed May 12, 2025. Owners may contact International customer service at 1-800-448-7825. International's number for this recall is 25501.

• SERVICE BRAKES, HYDRAULIC:FLUID#23V397000June 2, 2023

  Navistar, Inc. (Navistar) is recalling certain 2016 International DuraStar, 2018-2020 and 2023-2024 International 1300FBC Stripped chassis, 2019-2022 IC Bus CE Commercial bus, 2019-2024 IC Bus TC Commercial bus, and 2019-2024 International MV vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

  Risk: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

  Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch and if necessary, the wire harness or fuse, free of charge. Owner notification letters were mailed September 29, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23517.

• EXTERIOR LIGHTING:BACK UP LIGHTS#23V353000May 18, 2023

  Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

  Risk: Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.

  Remedy: Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.

• ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM#23V119000February 23, 2023

  Navistar, Inc. (Navistar) is recalling certain 2018-2021 International HV, 2019-2021 International RH, 2019-2022 International MV, and 2022 International HX vehicles. A software error in the Body Control Module (BCM) may allow the vehicle to overcome the park brake during power-take-off (PTO) operation.

  Risk: A parking brake that does not hold can allow the vehicle to move unexpectedly and increase the risk of a crash or injury.

  Remedy: Dealers will update the BCM software, free of charge. Owner notification letters are expected to be mailed April 24, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23503.

• FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL#21V366000May 19, 2021

  Navistar, Inc. (Navistar) is recalling certain 2018-2019 International WorkStar, International DuraStar, 2019-2021 International HV, International MV, and IC Bus RE Commercial Bus vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

  Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

  Remedy: Dealers will inspect the rail threads, and replace the rail as necessary, free of charge. Owner notification letters were mailed on June 21, 2021. Owners may contact Navistar customer service at 1-800-448-7825.

• ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM):SOFTWARE#20V810000December 23, 2020

  Navistar, Inc. (Navistar) is recalling certain 2019-2021 International MV, 2020-2021 International HV, 2014-2020 International DuraStar and 2015-2018 International WorkStar vehicles. When the parking brake is applied and the automatic transmission is still in the drive or reverse position and the stationary PTO switch is engaged by the operator, the engine may rev and overcome the parking brake's ability to keep the vehicle from moving.

  Risk: Unexpected Vehicle movement can increase the risk of a crash or injury.

  Remedy: Navistar will notify owners, and dealers will update the parameters in the Cummins ECM for feature codes 12VXT or 12VXU that enables the PTO neutral interlock, free of charge. The recall began February 17, 2021. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 20510.

• FUEL SYSTEM, DIESEL: PRE-HEATER#20V219000April 17, 2020

  Navistar, Inc. (Navistar) is recalling certain 2017-2020 International WorkStar and International DuraStar, 2018-2019 IC 1300 FBC Commercial and IC HC Commercial, 2018-2021 IC CE Commercial, International MV and International HV, and 2019-2021 IC TC Commercial buses with Cummins B6.7 diesel engines with a fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

  Risk: A fire increases the risk of injury. An engine stall can increase the risk of a crash.

  Remedy: Cummins will notify the affected Navistar customers and dealers will disable the fuel heater by either installing a plug in place of the heater or otherwise rendering the fuel heater inoperable and removing the fuse supplying electrical power to the fuel heater and installing a cover over the wire harness connector, free of charge. The recall began May 28, 2020. Owners may contact Cummins customer service at 1-800-286-6467.

• ENGINE#19V841000November 21, 2019

  Navistar, Inc. (Navistar) is recalling certain 2019-2020 International MV and HV, 2018-2020 Workstar, and 2018-2019 Durastar vehicles equipped with feature codes 12VXT and 12VXU. With the parking brake applied and the automatic transmission in the 'Drive' or 'Reverse' position, when the stationary PTO switch is engaged by the operator, the engine RPM will ramp up and may overcome the parking brake's ability to hold the vehicle.

  Risk: Unintended vehicle movement increases the risk of a crash.

  Remedy: Navistar will notify owners, and dealers will update the Engine Control Module to enable the PTO neutral interlock, free of charge. The recall began January 16, 2020. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 19518.

• FUEL SYSTEM, DIESEL: PRE-HEATER#19V216000March 20, 2019

  Navistar, Inc. (Navistar) is recalling certain 2017-2020 International DuraStar and WorkStar, 2018-2020 IC Bus CECB, International HV and MV, 2018-2019 IC Bus 1300 FBC and HCCB, and 2019-2020 IC Bus TCCB vehicles equipped with Cummins B6.7 diesel engines with fuel module option number FS90301 or FS90453. The electric fuel heater within the fuel module may overheat and cause plastic in the fuel heater to melt and potentially catch fire. It may also lead to engine stalling.

  Risk: A fire increases the risk of injury. An engine stall can increase the risk of crash.

  Remedy: Cummins will notify the affected Navistar owners. Cummins dealers will replace the fuel heater with a newly designed fuel heater, free of charge. The recall began May 2, 2019. Owners may contact Cummins customer service at 1-800-286-6467 or Navistar customer service at 1-800-448-7825.