RECALLS — HEARTLAND SUNDANCE
Heartland Sundance recalls
Heartland Sundance model years 2010–2024 covered by at least one recall campaign. Pick a year to see the Canadian and U.S. campaigns side by side.
Choose a model year
U.S. NHTSA campaigns are listed on each year page, where they are queried live by model year. The Canadian list below covers every year together.
Transport Canada recalls
12- Electrical#2024196
327 units affected
Issue: On certain RV trailers, the circuit board for the LED light rings on the cooktop knobs could fail. As a result, the wiring and/or LED lights could overheat and melt. Note: This recall only affects RV trailers equipped with certain Suburban cooktops. Safety Risk: Wiring and/or lights that overheat and melt can create the risk of a fire. Corrective Actions: Heartland will notify owners by mail and advise you to take your trailer to a dealership to disable or remove the LED light rings. To reduce the safety risk, Heartland recommends that you should disconnect the power for your trailer when it's not used.
- Accessories#2022437
588 units affected
Issue: On certain RV trailers, the fabric for the patio awning may not be properly attached. As a result, the awning could detach and fall from the trailer. Safety Risk: An awning that falls from the trailer could create a risk of injury. An awning that falls from a moving vehicle could create road hazard for others and increase the risk of a crash. Corrective Actions: Heartland will notify owners by mail and instruct you to take your trailer to a dealership to inspect the fabric roll on the awning. It will be repaired or replaced, as necessary.
- Electrical#2022239
11 units affected
Issue: On certain RV trailers, a rubber cover was not installed on the 12-V mini-breaker for the slide-out. As a result, the electrical studs on the breaker are exposed and could contact nearby ducting. This could cause a short circuit or electrical arcing (sparks). Safety Risk: A short circuit or electrical arcing could create the risk of a fire or injury. Corrective Actions: Heartland will notify owners by mail and instruct you to take your trailer to a dealership to inspect, and if necessary, install the missing rubber cover on the 12-V mini-breaker.
- Accessories#2022225
633 units affected
Issue: On certain RV trailers, the quick disconnect fittings for the propane (LP) gas system may be defective. As a result, the fittings could crack and leak propane. Safety Risk: A propane gas leak could create the risk of a fire or explosion. Corrective Actions: Heartland will notify owners by mail and instruct you to take your RV trailer to a dealership to inspect the quick disconnect fittings on the propane system. The quick disconnect fitting(s) will be replaced, if required. The dealer will also perform a leak test.
- Electrical#2019346
503 units affected
Issue: On certain travel trailers, the electrical connection for the air conditioning unit(s) may not have been assembled correctly. This could cause the connection to overheat, which could increase the risk of a fire. Safety Risk: A fire could create a risk of injury. Corrective Actions: Heartland RV will notify owners by mail and instruct them to take their trailer to a dealer to replace the connector for the air conditioning units.
- Visual System#2018694
29 units affected
Certain fifth wheel trailers may not comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 108 - Lighting System and Retroreflective Devices. The forward reflectors on one or both sides of the vehicle may be missing, which is contrary to requirements of the standard. This could decrease vehicle conspicuity and potentially increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will install the missing reflectors.
- Accessories#2017621
1,073 units affected
On certain travel trailers equipped with Kidde fire extinguishers with black plastic handles and valves, the fire extinguishers may become clogged or require excessive force to activate. Also, the nozzle may detach from the valve assembly with enough force that it could cause injury, and fail to discharge. In case of fire, failure of the extinguisher to function could result in injury and/or property damage. Correction: Owners will be provided with instructions on how to inspect the fire extinguisher to see if it is recalled. Replacement fire extinguishers will be supplied by Kidde directly. Note: For more information about recalled fire extinguishers, please visit <a href="https://inmarmarketaction.com/kidde/Kidde284CA/">www.kidde.com</a>.
- Lights And Instruments#2016415
428 units affected
On certain travel trailers, the switched accessory LED light that is located on the front cap of the camper may have a fault that could cause it to short circuit. Should a short occur, the wiring could overheat and cause a fire, which could increase the risk of injury and/or damage to property. Correction: Dealers will replace the current light with a different light which has built in voltage protection.
- Label#2015413
312 units affected
Certain vehicles fail to comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 110 or 120 - Tire Selection and Rims. The certification label may contain incorrect recommended tire size and tire pressure information. This could lead to tire under inflation and/or vehicle overloading, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will apply a revised label if necessary. Note: Although the information on the vehicle labels may be incorrect, tires of the correct size and rating were installed on the affected trailers.
- Suspension#2013158
12 units affected
On certain travel trailers, the axles may have been installed too far forward, which could adversely affect vehicle stability by reducing the amount of weight on the trailer’s tongue. Incorrectly distributed trailer weight could cause an uncontrolled swaying motion, which could result in a crash causing property damage and/or personal injury. Correction: Heartland will relocate the axles 30.5 cm (12 inches) aft of their current location.
- Other#2013152
122 units affected
On certain fifth wheels and travel trailers, the electrical motor for the awning could become damaged, allowing the awning to unfurl unexpectedly. As a result, the awning could strike another vehicle, a stationary object, or a bystander, causing property damage and/or personal injury. Correction: Dealers will replace the awning motor.
- Wheels#2010431
191 units affected
Certain fifth wheel and travel trailers originally equipped with spoke or modular design steel wheels may have poor weld quality between the wheel center disk and outer rim. The wheels which have a six (6) hole bolt pattern were manufactured by Xingmin Wheel and bear the rim stamp "07 10 06 Z" or "08 10 16 B" on the back side of the rim. The poor weld could cause the outer rim portion of the wheel to fail. A wheel separating from the vehicle could cause a loss of control and a crash. In addition, the errant wheel assembly could strike a vehicle, property, or a bystander. Both problems could cause property damage and/or personal injury. Correction: Dealers will inspect the wheels for the specific rim identification markings and replace as necessary.
Canadian data updated August 24, 2026
Does this recall apply to my vehicle?
Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.
What to do
Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, contact your manufacturer or dealer with your full VIN, or use the official channel:
- NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
- Defects and recalls database — Transport Canada