RECALLS — HEARTLAND PIONEER
Heartland Pioneer recalls
Heartland Pioneer model years 2013–2024 covered by at least one recall campaign. Pick a year to see the Canadian and U.S. campaigns side by side.
Choose a model year
U.S. NHTSA campaigns are listed on each year page, where they are queried live by model year. The Canadian list below covers every year together.
Transport Canada recalls
11- Electrical#2024196
327 units affected
Issue: On certain RV trailers, the circuit board for the LED light rings on the cooktop knobs could fail. As a result, the wiring and/or LED lights could overheat and melt. Note: This recall only affects RV trailers equipped with certain Suburban cooktops. Safety Risk: Wiring and/or lights that overheat and melt can create the risk of a fire. Corrective Actions: Heartland will notify owners by mail and advise you to take your trailer to a dealership to disable or remove the LED light rings. To reduce the safety risk, Heartland recommends that you should disconnect the power for your trailer when it's not used.
- Accessories#2022437
588 units affected
Issue: On certain RV trailers, the fabric for the patio awning may not be properly attached. As a result, the awning could detach and fall from the trailer. Safety Risk: An awning that falls from the trailer could create a risk of injury. An awning that falls from a moving vehicle could create road hazard for others and increase the risk of a crash. Corrective Actions: Heartland will notify owners by mail and instruct you to take your trailer to a dealership to inspect the fabric roll on the awning. It will be repaired or replaced, as necessary.
- Accessories#2022225
633 units affected
Issue: On certain RV trailers, the quick disconnect fittings for the propane (LP) gas system may be defective. As a result, the fittings could crack and leak propane. Safety Risk: A propane gas leak could create the risk of a fire or explosion. Corrective Actions: Heartland will notify owners by mail and instruct you to take your RV trailer to a dealership to inspect the quick disconnect fittings on the propane system. The quick disconnect fitting(s) will be replaced, if required. The dealer will also perform a leak test.
- Accessories#2021364
1,722 units affected
Issue: On certain RV trailers, the propane (LP) regulator could fail. If this happens, high-pressure propane could reach the appliances. Note: This recall only affects trailers equipped with a Winntec model 6020 propane regulator. Safety Risk: Unregulated propane pressure can create the risk of an appliance fire. Corrective Action: Heartland RV will notify owners by mail and instruct you to take your trailer to a dealer to replace the propane (LP) regulator.
- Electrical#2019346
503 units affected
Issue: On certain travel trailers, the electrical connection for the air conditioning unit(s) may not have been assembled correctly. This could cause the connection to overheat, which could increase the risk of a fire. Safety Risk: A fire could create a risk of injury. Corrective Actions: Heartland RV will notify owners by mail and instruct them to take their trailer to a dealer to replace the connector for the air conditioning units.
- Visual System#2018694
29 units affected
Certain fifth wheel trailers may not comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 108 - Lighting System and Retroreflective Devices. The forward reflectors on one or both sides of the vehicle may be missing, which is contrary to requirements of the standard. This could decrease vehicle conspicuity and potentially increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will install the missing reflectors.
- Accessories#2018608
34 units affected
On certain travel trailers, the outside cooktop was installed with a flexible rubber Liquid Propane (LP) hose where a rigid metal line should have been used. This is against the manufacturer’s recommendations and could result in damage to the flexible hose, which could increase the risk of a fire causing injury and/or damage to property. Correction: Dealers will replace the flexible LP hose on the outside cooktop with a rigid metal line.
- Suspension#2018511
16 units affected
On certain travel trailers, the axle bearings may not have been properly installed. This could cause the bearings to overheat and fail, potentially resulting in wheel separation. A wheel separating from the vehicle could cause a loss of control and a crash. In addition, the wheel assembly could strike another vehicle, stationary object, or bystander, causing injury and/or property damage. Correction: Dealers will repair or replace the axle hubs and bearings as necessary.
- Other#2017534
55 units affected
On certain travel trailers, the liquid propane (LP) manifold block may have been mounted too close to the center axle shackle. This could allow the shackle to make contact and potentially damage the LP block or LP hose fitting, which could increase the risk of a propane leak and could, in the presence of an ignition source, result in a fire causing injury and/or damage to property. Correction: Dealers will relocate the LP manifold block away from the shackle area.
- Accessories#2017402
19 units affected
On certain travel trailers, the liquid propane (LP) hoses may not be properly secured to the frame. If the hoses are not secured they could come in contact with the trailer’s tires, potentially damaging the hoses and resulting in an propane leak, which in the presence of an ignition source, could result in a fire causing injury and/or damage to property. Correction: Dealers will secure the LP hoses against the frame.
- Label#2015413
312 units affected
Certain vehicles fail to comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 110 or 120 - Tire Selection and Rims. The certification label may contain incorrect recommended tire size and tire pressure information. This could lead to tire under inflation and/or vehicle overloading, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will apply a revised label if necessary. Note: Although the information on the vehicle labels may be incorrect, tires of the correct size and rating were installed on the affected trailers.
Canadian data updated August 24, 2026
Does this recall apply to my vehicle?
Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.
What to do
Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, contact your manufacturer or dealer with your full VIN, or use the official channel:
- NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
- Defects and recalls database — Transport Canada