RECALLS — HEARTLAND MALLARD
Heartland Mallard recalls
Heartland Mallard model years 2016–2022 covered by at least one recall campaign. Pick a year to see the Canadian and U.S. campaigns side by side.
Choose a model year
U.S. NHTSA campaigns are listed on each year page, where they are queried live by model year. The Canadian list below covers every year together.
Transport Canada recalls
08- Accessories#2022437
588 units affected
Issue: On certain RV trailers, the fabric for the patio awning may not be properly attached. As a result, the awning could detach and fall from the trailer. Safety Risk: An awning that falls from the trailer could create a risk of injury. An awning that falls from a moving vehicle could create road hazard for others and increase the risk of a crash. Corrective Actions: Heartland will notify owners by mail and instruct you to take your trailer to a dealership to inspect the fabric roll on the awning. It will be repaired or replaced, as necessary.
- Accessories#2021378
44 units affected
Issue: On certain RV trailers, the propane (LP) lines on the outdoor cooktop may not have been properly tightened. As a result, the connection could leak propane gas. Safety Risk: A propane gas leak could create the risk of a fire or explosion. Corrective Action: Heartland RV will notify owners by mail and instruct you to take your trailer to a dealer to inspect and tighten the propane (LP) connection to the outside cooktop, as necessary. The dealer will also perform a leak test. To reduce the safety risk, Heartland recommends that you should not use the outside cooktop until the recall repairs have been completed.
- Accessories#2021364
1,722 units affected
Issue: On certain RV trailers, the propane (LP) regulator could fail. If this happens, high-pressure propane could reach the appliances. Note: This recall only affects trailers equipped with a Winntec model 6020 propane regulator. Safety Risk: Unregulated propane pressure can create the risk of an appliance fire. Corrective Action: Heartland RV will notify owners by mail and instruct you to take your trailer to a dealer to replace the propane (LP) regulator.
- Structure#2020213
57 units affected
Issue: On certain travel trailers with the spare tire mounted on the bumper, the U-bolts that hold the spare tire carrier to the travel trailer may break. This could cause the tire and carrier to separate from the trailer. Safety Risk: A spare tire carrier that falls from the trailer could become a hazard for other road users and bystanders. This could create a risk of injury and/or a crash. Corrective Actions: Heartland RV will notify owners by mail and instruct you to take your travel trailer to a dealer to replace the defective U-bolts. Heartland RV advises that you should remove the spare tire until the recall repairs have been completed.
- Suspension#2018511
16 units affected
On certain travel trailers, the axle bearings may not have been properly installed. This could cause the bearings to overheat and fail, potentially resulting in wheel separation. A wheel separating from the vehicle could cause a loss of control and a crash. In addition, the wheel assembly could strike another vehicle, stationary object, or bystander, causing injury and/or property damage. Correction: Dealers will repair or replace the axle hubs and bearings as necessary.
- Lights And Instruments#2016415
428 units affected
On certain travel trailers, the switched accessory LED light that is located on the front cap of the camper may have a fault that could cause it to short circuit. Should a short occur, the wiring could overheat and cause a fire, which could increase the risk of injury and/or damage to property. Correction: Dealers will replace the current light with a different light which has built in voltage protection.
- Label#2016232
21 units affected
Certain vehicles fail to comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 110 - Tire Selection and Rims. The certification label may contain incorrect recommended tire pressure information. This could lead to tire under inflation and/or vehicle overloading, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will apply a revised label if necessary. Note: Although the information on the vehicle labels may be incorrect, tires of the correct size and rating were installed on the affected trailers.
- Structure#2015142
27 units affected
On certain travel trailers, the Norco slide room mechanisms could be defective. The drive train that controls the inward and outward motion of the room could have been manufactured with incorrectly rated screws. If the screws were to fail, the slide room could extend while the vehicle is in motion, increasing the risk of crash causing injury and/or damage to property. Correction: Dealers will replace the defective screws with correctly rated bolts.
Canadian data updated August 24, 2026
Does this recall apply to my vehicle?
Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.
What to do
Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, contact your manufacturer or dealer with your full VIN, or use the official channel:
- NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
- Defects and recalls database — Transport Canada