2011 Ford F-350 recalls

• Other#2019420August 21, 2019

  5,327 units affected

  Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.

• Engine#2015125March 24, 2015

  96 units affected

  Certain ambulance or fire package vehicles with 6.7L diesel engines may experience a "stop safety now" warning message and 5 audible chimes if an Exhaust Gas Temperature (EGT) sensor fault is detected. Engine torque would be gradually reduced by 70 percent over a period of 45 seconds to a power-reduced level that is maintained. During this time, there would be no effect on steering, braking, lighting, electrical, or restraint systems, allowing the operator to maneuver the vehicle to a safe location. Such an occurrence could also result in an engine shut down and subsequent inability to quickly restart the vehicle. If this condition were to occur when an ambulance or fire engine vehicle was transporting a patient or providing medical assistance, it could delay medical treatment and increase the risk of injury to the patient. Correction: Dealers will reprogram the Powertrain Control Module with updated software.

• Airbag#2014103March 31, 2014

  101,212 units affected

  Certain vehicles may not comply with Canada Motor Vehicle Safety Standard 208 - Occupant Protection in Frontal Impacts. Prescribed text may have been omitted from the airbag warning label in the French language only. As a result, the French-language warning label is more restrictive than the English. Correction: No corrective recall action is required as this technical non-compliance is deemed to be non-safety related.

• Engine#2013372October 30, 2013

  50 units affected

  Certain ambulance package vehicles with 6.7L diesel engines may experience a "stop safety now" warning message and 5 audible chimes while the vehicles gradually loses power, eventually resulting in the engine stalling when speed falls below 5 km/h. If this were to occur while the ambulance is transporting a patient, engine shutdown with no ability to restart could interfere with patient care and increase the risk of injury to the patient. Correction: Dealers will replace the exhaust gas temperature (EGT) sensor located downstream of the diesel particulate filter (DPF).

• Electrical#2010463December 23, 2010

  3,243 units affected

  On certain vehicles, the Body Control Module (BCM) may develop an internal short. If an electrical short occurs, an overheating condition may result in a vehicle fire causing property damage and/or personal injury. Correction: Dealers will inspect and, if necessary, replace the Body Control Module.

Canadian data updated August 24, 2026

• EQUIPMENT#14V498000August 13, 2014

  PJ's Truck Bodies & Equipment Co., (PJ's) is recalling certain 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis modified by PJ's and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.

  Risk: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

  Remedy: PJ's has notified owners and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on August 28, 2014. Owners may contact PJ's customer service at 1-866-475-8782.

• ENGINE#13V535000October 30, 2013

  Ford Motor Company (Ford) is recalling certain model year 2011-2012 F-350/450/550 Ambulance Package vehicles manufactured February 22, 2010, through October 19, 2012 and equipped with a 6.7L diesel engine. Due to an exhaust sensor problem, the vehicles may experience loss of power followed by an engine stall.

  Risk: An unexpected engine stall increases the risk of a crash. Additionally, if this were to occur when the ambulance is transporting a patient, there is an increased risk of injury to the patient.

  Remedy: Ford will notify owners, and dealers will replace the exhaust gas temperature sensor, free of charge. The recall began on November 25, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S10.

• ELECTRICAL SYSTEM:SOFTWARE#11V128000February 24, 2011

  FORD IS RECALLING CERTAIN MODEL YEAR 2011 FORD F-150, F-250, F-350, F-450, F-550, EDGE, AND LINCOLN MKX TRUCKS MANUFACTURED FROM OCTOBER 25, 2010, THROUGH NOVEMBER 20, 2010. THESE VEHICLES WERE INSPECTED USING INTEGRATED DIAGNOSTIC SYSTEM (IDS) THAT HAD A CUSTOM SOFTWARE ROUTINE TO READ THE SUSPECT BODY CONTROL MODULE (BCM) SERIAL NUMBER. BASED ON THE SERIAL NUMBER THE BCM WAS EITHER NOT AFFECTED OR REPLACED. THE CUSTOM SOFTWARE ROUTINE WAS NOT READING THE CORRECT SET OF CHARACTERS, AND WAS NOT ABLE TO IDENTIFY A BCM THAT REQUIRED REPLACEMENT AFFECTED BCMS MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.

  Risk: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH COULD RESULT IN A VEHICLE FIRE.

  Remedy: DEALER WILL INSPECT THE BODY CONTROL MODULE AND IF NECESSARY REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 7, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

• STRUCTURE:BODY#10V659000December 29, 2010

  FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150, F-250, F-350, F-450, F-550, EDGE AND LINCOLN MKX VEHICLES. DURING A SIX-DAY PRODUCTION PERIOD, THE SUPPLIER OF THE BODY CONTROL MODULE MANUFACTURED MODULES THAT MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.

  Risk: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH CAN RESULT IN AN UNATTENDED VEHICLE FIRE.

  Remedy: DEALER WILL REPLACE THE BODY CONTROL MODULE IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.