2021 Ford F-150 Super Crew recalls

• Visual System#2026369July 28, 2026

  7,362 units affected

  Issue: Under certain conditions, a software problem could cause part of the rearview camera image to be blocked. Canadian regulations require the full rearview image to display while the transmission is in reverse gear. Note: This recall only affects vehicles equipped with an 8-inch display and 360-degree cameras. Safety Risk: A rearview camera image that is not fully displayed could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the APIM software. Alternatively, you may schedule an appointment to have the update performed at a Ford dealership.

• Lights And Instruments#2026342July 14, 2026

  105 units affected

  Issue: This recall is for certain integrated trailer modules that were installed before delivery or purchased from a dealer as an aftermarket accessory. On certain vehicles, a software problem with the integrated trailer module (ITRM) may cause the trailer lights not to work when towing. This problem could also cause the trailer brakes not to work on certain vehicles. Note: This problem would cause a "Trailer brake module fault" message to be displayed and turn signal telltale to flash rapidly. Safety Risk: Trailer lights that don't work could make the vehicle less visible and cause following drivers not to recognize that the vehicle is braking or intends to turn or change lanes. These issues could increase the risk of a crash. Additionally, a loss of trailer brakes could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the ITRM software.

• Powertrain#2026311June 24, 2026

  33,012 units affected

  Issue: On certain vehicles, a problem in the transmission could cause the parking pawl to become damaged. As a result, when the transmission is shifted to Park, the vehicle could move if the parking brake is not applied. Safety Risk: A parked vehicle that rolls away could create the risk of an injury or a crash. Corrective Actions: To reduce the safety risk, Ford recommends that you should always use the parking brake when you park until the recall repairs are completed. Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the powertrain control module (PCM) software. The dealer will also inspect and, if necessary, replace any damaged transmission components.

• Lights And Instruments#2026079February 20, 2026

  627,267 units affected

  Issue: On certain vehicles, a software problem with the integrated trailer module (ITRM) may cause the trailer lights not to work when towing. This problem could also cause the trailer brakes not to work on certain vehicles. Note: This problem would cause a "Trailer brake module fault" message to be displayed and turn signal telltale to flash rapidly. This recall also affects certain Super Duty incomplete vehicles. Safety Risk: Trailer lights that don't work could make the vehicle less visible and cause following drivers not to recognize that the vehicle is braking or intends to turn or change lanes. These issues could increase the risk of a crash. Additionally, a loss of trailer brakes could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the ITRM software. Alternatively, you may schedule an appointment to have the update performed at a Ford dealership.

• Structure#2025587October 24, 2025

  23,437 units affected

  Issue: On certain vehicles, the moonroof wind deflector may not have been attached properly. As a result, the deflector could detach from the vehicle. Note: This recall also affects certain Super Duty incomplete vehicles. Safety Risk: A moonroof wind deflector that detaches from the vehicle could create a hazard for others and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, repair the moonroof wind deflector.

• Fuel System#2025366July 8, 2025

  107,534 units affected

  Issue: On certain vehicles, the low-pressure fuel pump could fail. If this happens, the engine may run rough or may not start and the check engine light may turn on. This could also result in a sudden loss of engine power while driving. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the powertrain control module software. For Super Duty models, the dealer will replace the fuel pump.

• Visual System#2025260May 9, 2025

  159,135 units affected

  Issue: On certain vehicles, a software problem could cause the rearview camera image not to display or to freeze when the transmission is shifted into reverse. Safety Risk: A rearview camera image that doesn't display correctly could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the SYNC software. Alternatively, you may schedule an appointment to have the update performed at a Ford dealership.

• Powertrain#2025137March 14, 2025

  14 units affected

  Issue: On certain trucks, the recall repairs completed by a Ford dealer during recall 22S15 (Transport Canada recall no. 2022-144) may not have been done correctly. As a result, a second repair is required. On certain trucks, the powertrain control module (PCM) may have been programmed incorrectly. As a result, a false diagnostic trouble code (DTC) could cause the transmission to shift into neutral while driving, causing a sudden loss of power to the wheels. If the vehicle speed drops below 3 km/h after this happens, the transmission can shift to park automatically. Note: This recall only affects trucks equipped with a 2.7 L, 3.5 L, or 5.0 L engine and without auto start-stop technology. Safety Risk: A loss of power to the wheels could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your truck to a dealership to update the powertrain control module (PCM) software.

• Brakes#2025106March 2, 2025

  10,627 units affected

  Issue: On certain vehicles, the recall repairs completed by a Ford dealer during recall 22S17 (Transport Canada recall no. 2022-146) may not have been done correctly. As a result, a second repair is required. On certain vehicles, a software problem in the trailer brake controller could cause the trailer brakes not to apply when you brake. Note: This recall only affects vehicles equipped with the optional trailer brake controller. Safety Risk: A loss of trailer brakes could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the integrated trailer brake control module software.

• Engine#2024492August 23, 2024

  11,821 units affected

  Issue: On certain vehicles, the intake valves may not have been manufactured properly. As a result, the valves could break and cause the engine to fail. Note: This recall only affects certain vehicles equipped with a 2.7L or 3.0L EcoBoost engine. This problem would cause the engine to run rough and the engine malfunction indicator lamp to turn on. Safety Risk: An engine failure could cause a sudden loss of power to the wheels and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the engine.

• Lights And Instruments#2024347June 14, 2024

  22 units affected

  Issue: On certain vehicles, a previous over-the-air (OTA) software update could cause the backup lamps not to turn on when the vehicle is reversing. Safety Risk: Backup lamps that don't work could cause others not to recognize when a vehicle is backing up, and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the body control module software.

• Powertrain#2023705December 22, 2023

  20,664 units affected

  Issue: On certain trucks, the rear axle hub bolt(s) could break and cause the axle shaft(s) splines to wear. If this happens, there could be a loss of power to the wheels. Additionally, if the truck is parked and the parking brake isn't applied, the truck could roll away. Note: This recall only affects trucks equipped with the Trailer Tow Max Duty optional package. Safety Risk: A loss of power to the wheels could increase the risk of a crash. A parked vehicle that rolls away could create the risk of an injury or a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your truck to a dealership to replace the rear axle shafts.

• Brakes#2023405July 25, 2023

  171,442 units affected

  Issue: On certain trucks, the rear axle wiring harness could rub against the rear axle housing. Over time, this could cause damage to the wiring harness, and the electric parking brake could apply suddenly while driving. Safety Risk: A parking brake that self-applies while driving could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and secure the rear axle wiring harness. If damage is found, the dealer will replace the wiring harness.

• Visual System#2023133March 13, 2023

  49,639 units affected

  Issue: On certain trucks, the windshield wiper arms may not have been manufactured correctly. As a result, the wiper arms could slip and they may not wipe the windshield properly. Note: This problem could cause slow or erratic wiper arm movement. Safety Risk: Windshield wipers that do not work properly could affect a driver's visibility. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to replace the windshield wiper arms.

• Visual System#2022650November 15, 2022

  106,044 units affected

  Issue: On certain trucks, the windshield wiper motor may fail. If this happens, the windshield wipers will not work. Safety Risk: Windshield wipers that do not work could affect a driver's visibility and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your truck to a dealer to replace the windshield wiper motor.

• Structure#2022461August 12, 2022

  11,349 units affected

  Issue: On certain trucks, the insulators under the truck may have been installed in error. As a result, it could loosen and damage the driveshaft. If this happens, the driveshaft could break and cause a loss of power to the wheels. A broken driveshaft could also contact the ground and cause a loss of control. Additionally, the truck could move when the transmission is in Park and the parking brake is not used. Note: This recall only affects certain 4x4 models with a 145" wheelbase that have specific trim packages and an aluminum driveshaft. Safety Risk: A loss of power to the wheels or a loss of control could increase the risk of a crash. A parked vehicle that rolls away could also create the risk of an injury or a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your truck to a dealership inspect if underbody insulators are installed and add new attachments as required. The dealer will also inspect the driveshaft for damage and repair it, as necessary.

• Brakes#2022279May 30, 2022

  1,238 units affected

  Issue: This recall is for accessory trailer brake controllers that were dealer-installed or sold as an accessory part at a Ford dealership. A software problem in the trailer brake controller could cause the trailer brakes not to apply when you brake. Safety Risk: A loss of trailer brakes could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to update the integrated trailer brake control module software.

• Visual System#2022197April 14, 2022

  77,815 units affected

  Issue: On certain trucks, the windshield wiper arms may not have been manufactured correctly. As a result, the wiper arms could slip and they may not wipe the windshield properly. Safety Risk: Windshield wipers that do not work properly could affect a driver's visibility. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to replace the windshield wiper arms.

• Brakes#2022146March 29, 2022

  95,896 units affected

  Issue: A software problem in the trailer brake controller could cause the trailer brakes not to apply when you brake. Note: This recall only affects vehicles equipped with the optional trailer brake controller. Safety Risk: A loss of trailer brakes could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to update the integrated trailer brake control module software.

• Powertrain#2022144March 28, 2022

  4,225 units affected

  Issue: On certain trucks, the powertrain control module (PCM) may have been programmed incorrectly. As a result, a false diagnostic trouble code (DTC) could cause the transmission to shift into neutral while driving, causing a sudden loss of power to the wheels. If the vehicle speed drops below 3 km/h after this happens, the transmission can shift to park automatically. Note: This recall only affects trucks equipped with a 2.7 L, 3.5 L, or 5.0 L engine and without auto start-stop technology. Safety Risk: A loss of power to the wheels could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your truck to a dealership to update the powertrain control module (PCM) software.

• Visual System#2022116March 14, 2022

  34,734 units affected

  Issue: On certain trucks, the windshield wiper motor may fail. If this happens, the windshield wipers will not work. Safety Risk: Windshield wipers that do not work could affect a driver's visibility and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your truck to a dealer to replace the windshield wiper motor.

• Powertrain#2021775December 17, 2021

  40,362 units affected

  Issue: On certain trucks, the insulation under the truck may loosen and damage the driveshaft. If this happens, the driveshaft could break and cause a loss of power to the wheels. A broken driveshaft could also contact the ground and cause a loss of control. Additionally, the truck could move when the transmission is in Park and the parking brake is not used. Note: This recall only affects certain SuperCrew 4x4 models with a 5.5' box that have specific options and an aluminum driveshaft. Safety Risk: A loss of power to the wheels or a loss of control could increase the risk of a crash. A parked vehicle that rolls away could also create the risk of an injury or a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your truck to a dealer to add new attachments for the underbody insulators. The dealer will also inspect the driveshaft for damage and repair it, as necessary.

• Airbag#2021638October 18, 2021

  61 units affected

  Issue: On certain vehicles, the side-impact sensors in the front doors may have been damaged during assembly. As a result, the side airbags may not work properly in a side-impact crash. Safety Risk: An airbag that does not work properly could create an increased risk of injury in a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a Ford dealer replace the driver and passenger-front door side-impact pressure sensors.

• Seats And Restraints#2021526August 23, 2021

  3,331 units affected

  Issue: On certain trucks, the driver and/or front passenger seat belts may not be properly routed through the anchor eyelets. As a result, the seat belts may not work as designed in a crash. Note: This recall only affects SuperCab body style trucks. Safety Risk: A seat belt that does not work properly could increase the risk of injury in a crash. Corrective Actions: Ford will notify owners by mail and provide you with instructions for inspecting the driver and front passenger seat belts before using either seat. Depending on the results, Ford advises that you should take the following steps: 1. If the seat belts pass the inspection, you should schedule an appointment and take your truck to a dealer to inspect and replace the seat belt retractor and pretensioner assemblies, as necessary. 2. If the driver's seat belt does not pass the self-inspection, or you are uncertain of the results of your inspection, you should not drive your truck and contact your dealer to make arrangements to have it towed for an inspection. 3. If the front passenger's seat belt does not pass the self-inspection, do not use that seat unit the seat belt has been inspected by a dealer.

• Steering#2021337May 31, 2021

  90 units affected

  Issue: On certain trucks, there may be an internal problem with the steering gear. As a result, the steering could suddenly become stiff or lock up while driving. Safety Risk: A sudden change in steering effort or a loss of steering control could create the risk of a crash. Corrective Actions: Ford will contact owners and instruct you not to drive your truck. Ford will ask you to contact a dealer and arrange to have it towed to the dealership for a replacement of the steering gear.

• Powertrain#2021307May 24, 2021

  1,415 units affected

  Issue: On certain trucks, the two-piece driveshaft could disconnect while driving and cause a loss of power to the wheels. If this happens, the truck could also move when the transmission is in Park, and the parking brake is not used. Note: This recall only affects trucks with a 3.5 L gas engine rated for maximum trailer towing capacity or a 3.5 L HEV engine. Safety Risk: A loss of power to the wheels could increase the risk of a crash. A parked vehicle that rolls away could also create the risk of an injury or a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your truck to a dealer to inspect, and if necessary, replace the driveshaft assembly.

• Structure#2021085February 19, 2021

  6,986 units affected

  Issue: On certain trucks, the windshield may not be properly attached. As a result, the glass can become loose and could separate from the truck in a crash. Safety Risk: A windshield that detaches in a crash could create an increased risk of injury. Corrective Actions: Ford will notify owners by mail and instruct you to take your truck to a dealer to remove and reinstall the windshield.

Canadian data updated August 24, 2026

No recalls found for this make, model, and year.