Does the 2018 E-ONE Typhoon have any recalls?

Transport Canada lists 2 campaigns and the U.S. NHTSA lists 7 for the 2018 E-ONE Typhoon. Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.

How do I know if a recall applies to my 2018 E-ONE Typhoon?

Recalls are matched by make, model and model year, but many cover only certain VIN ranges. Confirm with your manufacturer or dealer using your full VIN, or use the official Transport Canada or NHTSA lookup.

Are recall repairs free?

Yes. In both Canada and the United States the manufacturer must fix a recalled defect at no charge, through a franchised dealer.

RECALLS — MAKE · MODEL · YEAR

2018 E-ONE Typhoon recalls

9 safety recall campaigns have been filed for the 2018 E-ONE Typhoon with Transport Canada and the U.S. NHTSA. Here is what both agencies say.

Canadian recalls: 02
U.S. recalls: 07
Total campaigns: 09

Transport Canada recalls

Fuel System#2021275May 11, 2021
65 units affected
Issue: On certain vehicles, the fuel rail assembly could develop a leak. Note: This recall only affects vehicles equipped with a Cummins L9 or ISX12 diesel engine. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Cummins will notify owners by mail and instruct you to take your vehicle to a Cummins authorized service center to inspect the fuel rail. If damage is found, the fuel rail and fuel lines will be replaced. If no damage is found, the fuel rail will be reassembled with new crush washers using a special tool.
Electrical#2019517October 14, 2019
112 units affected
Issue: On certain vehicles, the starter lock-out relay could be damaged over time, causing it to fail. If this happens, it will not be possible to start the engine. Note: A possible symptom of a damaged starter lock-out relay is a truck that requires multiple attempts to start. Safety Risk: An emergency vehicle with an engine that cannot be started could increase the risk of injury in an emergency situation. Corrective Actions: E-One will notify owners by mail and instruct them to take their vehicle to a service center to install a relay and diode kit.

Canadian data updated August 24, 2026

U.S. NHTSA recalls

FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL#21V332000May 11, 2021
E-One Incorporated (E-One) is recalling certain 2017-2021 Cyclone 2, Cyclone N, Quest 2, Typhoon, and Typhoon N vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will inspect and replace the rail as necessary, free of charge. Owner notification letters were mailed out on May 28, 2021. Owners may contact E-One customer service at 1-352-237-1122.
POWER TRAIN:AXLE ASSEMBLY#20V546000September 9, 2020
E-One Incorporated (E-One) is recalling certain 2018-2020 Cyclone 2 and Typhoon ambulances. The lower shock mount bracket may cause the U-bolts to bind and break, possibly preventing the rear axle from remaining secured.
Risk: The unsecured rear axle may shift sideways, resulting in loss of control of the vehicle, thereby increasing the risk of crash.
Remedy: E-One has notified owners, and dealers replace any of the affected lower shock mount brackets, free of charge. The recall began September 21, 2020. Owners may contact E-One customer service at 1-888-237-1751.
ELECTRICAL SYSTEM:STARTER ASSEMBLY#19V730000October 14, 2019
E-One Incorporated (E-One) is recalling certain 2013-2019 Typhoon and Cyclone 2, 2013-2014 Cyclone 3, 2014-2019 Quest 2 and 2017 CHSH emergency vehicles equipped with a Cummins ISL, L9, ISX12, X12, ISX15, or X15 engine. The engines do not have a diode in the starter solenoid circuit to improve the longevity of the lock-out relay, resulting in accumulated damage over time.
Risk: The damaged starter lock-out relay may prevent the vehicle from starting, hindering personnel from responding to emergencies, increasing the risk of an injury.
Remedy: E-One will notify owners, and dealers will install a diode in the starter solenoid circuit and install a new starter lock-out relay, free of charge. The recall began November 15, 2019. Owners may contact E-One customer service at 1-352-861-3612. Note: Vehicles previously repaired under recall 18V-019 also need this recall remedy.
EQUIPMENT#19V649000September 10, 2019
E-One Incorporated (E-One) is recalling one 2018 Typhoon emergency vehicle equipped with a Hale SmartFoam 6.5 foam pump system with a 12 volt power supply. The foam pump system can overheat and fail, causing fire fighting foam chemical to be unavailable to fight a fire.
Risk: If the fire fighting foam chemical injection is unavailable, it can impact the fire fighting and/or vapor mitigation efforts, which increases the risk of injury to bystanders and emergency personnel.
Remedy: E-One will notify owners, and a Hale dealer will replace the SmartFoam 6.5 12 volt system with SmartFoam 6.5 24 volt system and a voltage converter, free of charge. The recall began October 15, 2019. Owners may contact E-One customer service at 1-352-861-3612 or Hale at 1-800-533-3569.
SUSPENSION:FRONT#19V598000August 14, 2019
E-One Incorporated (E-One) is recalling certain 2014-2019 Cyclone II, 2013-2014 and 2016-2019 Typhoon, 2015-2017 Quest fire trucks. The front shocks may separate from their upper mount on the front suspension. The loose shock may contact and damage the steering gear housing, possibly causing a steering fluid leak and a loss of power steering assist.
Risk: A loss of hydraulic steering assist can increase the risk of a crash.
Remedy: E-One has notified owners, and dealers will install a new shock mount bolt and nut, hardened washer, and shims to keep the shocks secured, free of charge. The recall began August 28, 2019. Owners may contact E-One customer service at 1-352-861-3612.
SUSPENSION:REAR#18V748000October 22, 2018
E-One Incorporated (E-One) is recalling certain 2016-2018 E-One Cyclone II and Typhoon aerial devices. The torque rod tower may crack causing failure of the tower, possibly affecting vehicle handling.
Risk: If the torque rod tower fails and affects vehicle handling, it can increase the risk of a crash.
Remedy: E-One will notify owners, and direct owners to contact the manufacturer of the Atlas suspension for replacement parts, free of charge. The recall began January 10, 2019. Owners may contact E-One customer service at 1-352-861-3612.
EXTERIOR LIGHTING:BRAKE LIGHTS#18V606000September 11, 2018
E-One Incorporated (E-One) is recalling certain 2017-2019 Cyclone II, Typhoon and Quest II emergency vehicles, equipped with Whelen accessory brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Remedy: E-One will notify owners, and dealers will replace the brake lights, free of charge. The recall began October 26, 2018. Owners may contact E-One customer service at 1-352-861-3612.

Does this recall apply to my vehicle?

Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.

What to do

Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, or to book the work, contact your manufacturer or dealer with your full VIN, or use the official channel:

NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
Defects and recalls database — Transport Canada

Check a 2018 E-ONE Typhoon VIN

A VIN decode confirms your vehicle's exact model year, trim and assembly plant, then runs this same recall check against it.

Data sources and coverage limits →