Does the 2011 E-ONE Typhoon have any recalls?

Transport Canada lists 4 campaigns and the U.S. NHTSA lists 4 for the 2011 E-ONE Typhoon. Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.

How do I know if a recall applies to my 2011 E-ONE Typhoon?

Recalls are matched by make, model and model year, but many cover only certain VIN ranges. Confirm with your manufacturer or dealer using your full VIN, or use the official Transport Canada or NHTSA lookup.

Are recall repairs free?

Yes. In both Canada and the United States the manufacturer must fix a recalled defect at no charge, through a franchised dealer.

RECALLS — MAKE · MODEL · YEAR

2011 E-ONE Typhoon recalls

8 safety recall campaigns have been filed for the 2011 E-ONE Typhoon with Transport Canada and the U.S. NHTSA. Here is what both agencies say.

Canadian recalls: 04
U.S. recalls: 04
Total campaigns: 08

Transport Canada recalls

Wheels#2018206April 25, 2018
1 units affected
On certain vehicles, a manufacturing problem could lead to the development of a fatigue crack in the front spindles. This could cause a spindle failure and result in the possible separation of a wheel from the vehicle, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the defective front spindles.
Other#2011435December 20, 2011
19 units affected
On certain fire trucks, specific operating conditions (such as tight, successive, highly banked curves in opposite directions), could trigger unintended Electronic Stability Control (ESC) system intervention. As a result, the ESC may unnecessarily apply one of the front brakes in order to correct the perceived oversteer condition. This may cause the vehicle to deviate from the intended path, thereby increasing the risk of a crash causing property damage and/or personal injury. Correction: Dealers will replace the ESC module.
Engine#2011341September 14, 2011
2 units affected
On certain fire trucks equipped with a Cummins engine, the V-band clamps used to connect the inlet and outlet cone sections to the Diesel Oxidation Catalyst (DOC) / Diesel Particulate Filter (DPF) include a T-bolt which can fracture and fail when subjected to stress or load. A fracture or failure of the T-bolt may cause the clamp to loosen and the inlet or outlet sections attached to the DOC/DPF housing to disconnect. Should this occur, hot exhaust gases can vent prior to exiting the tailpipe, creating a risk of combustion or damage to adjacent materials, which could result in a vehicle fire. If both clamps fail, the DOC/DPF housing could detach completely, separate from the vehicle, and strike another vehicle, stationary object, or bystander. These issues could result in property damage and/or personal injury. Correction: Cummins will install updated V-band clamps.
Accessories#2011336September 13, 2011
5 units affected
On certain fire trucks, the door latch fasteners may not have received adequate tightening torque during the manufacturing process. As a result, the outer door handle may rotate out of position, allowing a retention spring to dislocate, which could cause the door to open during a vehicle crash. Should this occur, unbelted occupants could fall out of the vehicle and sustain personal injury. Correction: E-One service centers will replace the door latch assemblies.

Canadian data updated August 24, 2026

U.S. NHTSA recalls

SUSPENSION:FRONT#18V171000March 15, 2018
E-One Incorporated (E-One) is recalling certain 2008-2015 E-One Typhoon, Cyclone II, and Quest II vehicles, equipped with Timoney Independent Front Suspensions. Inconsistent machining may result in fatigue cracks developing over time in the front axle spindles, causing failure of the spindle and the possible separation of a front wheel from the vehicle.
Risk: A wheel separation from the vehicle can increase the risk of a crash.
Remedy: E-One will notify owners, and dealers will replace the front axle spindle, free of charge. The recall began on April 24, 2018. Owners may contact E-One customer service at 1-352-861-3612.
ELECTRONIC STABILITY CONTROL (ESC)#11V564000December 1, 2011
E-ONE IS RECALLING CERTAIN MODEL YEAR 2008 THROUGH 2011 CYCLONE II, TYPHOON, AND QUEST VEHICLES MANUFACTURED FROM MAY 1, 2008, THROUGH NOVEMBER 28, 2011, AND EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
Risk: IF THE DRIVER IS SLOW TO REACT DURING THIS ESC INTERVENTION, THE VEHICLE MAY DEVIATE FROM THE INTENDED LINE OF TRAVEL, INCREASING THE RISK OF A CRASH.
Remedy: E-ONE WILL NOTIFY OWNERS AND IS WORKING WITH MERITOR WABCO TO REPLACE THE CONTROL MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 16, 2011. OWNERS MAY CONTACT E-ONE CUSTOMER SERVICE AT 1-800-627-5050 OR MERITOR ON TRACK CUSTOMER SERVICE AT 1-866-668-7221.
ENGINE AND ENGINE COOLING#11V443000August 17, 2011
E-ONE IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 TYPHOON AND CYCLONE II AND MODEL YEAR 2011 TRADITION AND QUEST FIRE FIGHTING CHASSIS MANUFACTURED FROM NOVEMBER 24, 2010, THROUGH JULY 13, 2011, EQUIPPED WITH A CUMMINS ISB, ISL, ISC, or ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
Risk: THIS COULD RESULT IN ASPHYXIATION OR CARBON MONOXIDE POISONING. THE HEAT BUILD UP FROM THE EXHAUST CAN ALSO RESULT IN A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.
Remedy: E-ONE IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR E-ONE AT 1-352-861-3223.
LATCHES/LOCKS/LINKAGES:DOORS:LATCH#11V357000July 13, 2011
E-ONE IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 TYPHOON, CYCLONE II, AND TRADITION FIRE FIGHTING VEHICLES MANUFACTURED FROM JANUARY 1, 2010, THROUGH JULY 1, 2011, EQUIPPED WITH TRIMARK CAB DOOR MOUNT BRACKET PART NUMBERS 28141-01 AND 28142-01. IF THE MOUNTING FASTENERS ARE NOT AT PROPER TORQUE VALUE, THE OUTSIDE DOOR HANDLE MOUNT BRACKET MAY POTENTIALLY ROTATE OUT OF POSITION. THE DOOR SYSTEM MAY FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Risk: THE DOOR MAY NOT STAY CLOSED AND COULD OPEN WITHOUT WARNING DURING A CRASH. PERSONS OR OBJECTS COULD FALL FROM THE VEHICLE, POSSIBLY RESULTING IN INJURY.
Remedy: E-ONE IS WORKING WITH TRIMARK AND TRIMARK WILL NOTIFY VEHICLE OWNERS USING E-ONE LETTERHEAD. REPAIRS WILL BE MADE BY E-ONE SERVICE CENTERS OR BY TRIMARK PERSONNEL AS NEEDED. REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 22, 2011. OWNERS MAY CONTACT TRIMARK AT 1-641-394-1095 OR E-ONE AT 1-352-861-3223.

Does this recall apply to my vehicle?

Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.

What to do

Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, or to book the work, contact your manufacturer or dealer with your full VIN, or use the official channel:

NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
Defects and recalls database — Transport Canada

Check a 2011 E-ONE Typhoon VIN

A VIN decode confirms your vehicle's exact model year, trim and assembly plant, then runs this same recall check against it.

Data sources and coverage limits →