2021 Volvo VHD recalls

• Brakes#2024633October 23, 2024

  19,251 units affected

  Issue: On certain trucks, poor signal strength could cause the electronic control unit (ECU) to stop working or not to work properly. As a result, some safety systems may not work, including the antilock braking system, automatic traction control, electronic stability control, active cruise control and the collision mitigation system. Note: For the VNR model, this recall affects only the VNRe model. Safety Risks: Vehicle safety systems that don't work correctly could increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and advise you to take your truck to a dealership to reprogram the ECU software.

• Wheels#2021342June 2, 2021

  135 units affected

  Issue: On certain trucks, the hubcaps may be defective and could come loose or detach while driving. Safety Risk: A hubcap that detaches from the truck could create a road hazard for others. Corrective Actions: Volvo Trucks will notify owners by mail and instruct you to take your truck to a dealer to remove the hubcaps.

• Lights And Instruments#2021120March 5, 2021

  283 units affected

  Issue: On certain trucks, when the manual override is used to switch off the daytime running lamps (DRLs), the lights may not turn on again when you start driving. Canadian regulations require that if DRLs are manually turned off, they must turn on again when you start driving. Safety Risk: Driving without daytime running lights could make the vehicle less visible to others and increase the risk of a crash. Corrective Actions: Volvo Trucks will notify owners by mail and instruct you to take your truck to a dealer to update the vehicle software.

• Brakes#2020618December 15, 2020

  924 units affected

  Issue: On certain trucks, the fittings for the air brake lines on the firewall pass-through plate may have been damaged during assembly. As a result, an air line could detach from the fitting. If this happens, the parking brake could apply without warning. Note: The service brakes are not affected by this problem. Safety Risk: A parking brake that applies suddenly while driving could increase the risk of a crash. Corrective Actions: Volvo Trucks will notify owners by mail and instruct you to take your truck to a dealer to inspect the fittings on the pass-through plate. They will be repaired or replaced, as required.

• Brakes#2020417September 3, 2020

  1,825 units affected

  Issue: On certain trucks, the support plate for the brake pedal could fail. If this happens, the brake pedal could detach and cause a loss of braking. Safety Risk: A loss of brakes can create the risk of a crash. Corrective Actions: Volvo will notify owners by mail and instruct you to take your truck to a dealer to inspect the pedal plate. If a crack is found, the plate will be replaced.

Canadian data updated August 24, 2026

• ELECTRICAL SYSTEM:SOFTWARE#24V790000October 23, 2024

  Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2025 VN, VAH, VHD and VNRE trucks, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.

  Risk: Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may have diminished or lost functionality, increasing the risk of a crash.

  Remedy: Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed December 9, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Truck's number for this recall is RVXX2409.

• SEATS:CRITICAL FASTENERS#23V769000November 15, 2023

  Volvo Trucks North America (Volvo Trucks) is recalling certain 2019-2024 VN and VHD vehicles. The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seatbelt Assembly Anchorage."

  Risk: The attachment points may fail, allowing the bench seat to shift and increasing the risk of injury during a crash.

  Remedy: Dealers will replace the weld nut with two nuts and a washer, free of charge. Owner letters were mailed February 29, 2024. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks number for this recall is RVXX2312.

• WHEELS:HUB#21V417000June 2, 2021

  Volvo Trucks North America (Volvo Trucks) is recalling certain 2021-2022 VAH, VDH, VNL, AND VNR vehicles. The hubcap compression spring can cause the hubcap to separate.

  Risk: A separated hubcap can create a road hazard, increasing the risk of a crash.

  Remedy: Dealers will remove the hubcap, free of charge. Owner notification letters were mailed on July 12, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Mack's number for this recall is RVXX 2102.

• SERVICE BRAKES, HYDRAULIC:CRITICAL FASTENERS#20V782000December 15, 2020

  Volvo Trucks North America (Volvo Trucks) is recalling 2021 VNL, VNR, VAH, and VHD vehicles. The collets (internal jaws) for the brass fitting inserts used in the pneumatic pass-through plate may have been damaged during leak testing. As a result, the brass fitting may completely release the air brake line from the pass-through plate while under pressure. If this occurs on the park brake circuit, signal pressure that holds off the mechanical spring in the park brake chambers will be lost allowing the park brakes to apply.

  Risk: If the park brakes apply unexpectedly, the driver may lose control of the vehicle, increasing the risk of a vehicle crash.

  Remedy: Volvo Trucks will notify owners, and dealers will inspect the air brake line for proper engagement of the fitting in the pass-through plate, free of charge. The recall is expected to begin January 31, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2006.

• STEERING#20V535000September 2, 2020

  Volvo Trucks North America (Volvo Trucks) is recalling certain 2021 VNL, VHD, and VNR vehicles. The king pin nut may not have been installed or properly tightened during axle assembly.

  Risk: If the king pin is missing or not tightened properly, the knuckle may separate from the axle, increasing the risk of a crash.

  Remedy: Volvo Trucks will notify owners, and dealers will inspect the vehicle to make sure that the king pin nut is installed and that it properly tightened, free of charge. The recall began September 28, 2020. Owners may contact Volvo Trucks customer service at 1-800-458-1522. Volvo Truck's number for this recall is RVXX 2003.

• SERVICE BRAKES, AIR#20V536000September 2, 2020

  Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2021 VAH, VHD, VNL and VNR vehicles. The die cast pedal plate may break at one of its attachment points, possibly resulting in the brake pedal dislodging. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."

  Risk: A dislodged brake pedal would be inoperable, increasing a risk of a crash.

  Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the pedal plates if required, free of charge. The recall began October 7, 2020. Owners may contact Volvo Trucks customer service at 1-800-458-1552. Volvo Truck's number for this recall is RVXX2004.