Toyota Avalon recalls

• Airbag#2023684December 20, 2023

  99,965 units affected

  Issue: On certain vehicles, a sensor for the occupant classification system (OCS) may not have been manufactured properly. As a result, the sensor could short circuit and cause the airbag system to turn off the passenger-front airbag even when a passenger is seated. Note: This problem would cause a warning message to display on the instrument panel and the airbag indicator light would display "passenger airbag off". Safety Risk: An airbag that is turned off could increase the risk of injury to a passenger in a crash. Corrective Actions: Toyota will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the OCS sensor.

• Electrical#2021723November 24, 2021

  55,683 units affected

  Issue: This recall is for certain block heater kits installed on certain vehicles or sold as accessories at Toyota or Lexus dealerships. On certain vehicles, the engine block heater cable may not have enough heat protection and could be damaged by high temperatures. If this happens, the cable could short circuit while plugged in, and cause the wiring to overheat or melt. Note: This recall only affects the following block heater/cord part numbers: C014003034 PK5A408J09 PU14000904 C014003151 PK5A408J13 PU14000905 C014000885 PK5A489J11 PU14000907 C014000888 PK5A489J22 PU14000909 C014000907 PK5A410H00 PU14000911 C014100904 PU14000900 PU14000913 C014100907 PU14000901 PU14003571 C014100911 PU14000902 PK5A489J14 PK5A408J05 PU14000903 Safety Risk: Engine block heater wiring that overheats or melts could create the risk of a fire. Corrective Actions: Toyota recommends that you should stop using the engine block heater immediately. Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to disable the engine block heater. For some vehicles, the corrective actions for this recall are under development. For others, a new engine block heater cannot be installed, and the owner will receive a refund of the purchase price of the engine block heater.

• Fuel System#2020514October 28, 2020

  126,597 units affected

  Issue: On certain vehicles, the low-pressure fuel pump could fail. If this happens, then engine may run rough or may not start and the check engine light may turn on. This could also result in a sudden loss of engine power while driving. Note: This recall is an expansion of recalls SRC R95/SRC R96 and SRC RA2/SRC RA3 (Transport Canada Recall Numbers 2020-005 and 2020-088). Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct you to take your vehicle to a dealer to replace the fuel pump.

• Fuel System#2020088March 4, 2020

  111,835 units affected

  Issue: On certain vehicles, the low-pressure fuel pump could fail. If this happens, then engine may run rough or may not start and the check engine light may turn on. This could also result in a sudden loss of engine power while driving. Note: This recall is an expansion of recall SRC R95/SRC R96 (Transport Canada Recall No. 2020-005) Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct you to take your vehicle to a dealer to replace the fuel pump.

• Airbag#2020013January 17, 2020

  407,318 units affected

  Issue: On certain vehicles, the circuits within the airbag control module could be damaged in a crash. This could cause the airbags and seat belt pretensioners to not deploy in certain crashes. Safety Risk: Airbags or seat belts that do not work properly in a crash could create an increased risk of injury. Corrective Actions: Toyota will notify owners by mail and instruct you to take your vehicle to a dealer to install an electrical noise filter to prevent damage to the airbag control module.

• Fuel System#2020005January 13, 2020

  46,733 units affected

  Issue: On certain vehicles, the low-pressure fuel pump could fail. If this happens, then engine may run rough or may not start and the check engine light may turn on. This could also result in a sudden loss of engine power while driving. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct you to take your vehicle to a dealer to replace the fuel pump.

• Airbag#2018547October 5, 2018

  15,774 units affected

  Certain vehicles may not comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 208 - Occupant Protection in Frontal Impacts and CMVSS 214 - Side Impact Protection. The airbag (SRS) control unit may incorrectly detect a fault in one or more of the front or side airbag impact sensors during vehicle start up. In the event of a crash where airbag deployment is required, this may result in the airbags not deploying as designed, increasing the risk of injury. Upon detection of a fault in the airbag system, multiple warning lights would activate, a warning buzzer would sound, and a warning message would display on the instrument panel display. Correction: Dealers will update the airbag control unit software. Note: This recall supersedes recall 2018-100. Vehicles repaired as part of the previous recall will require re-inspection and repair.

• Seats And Restraints#2018457August 29, 2018

  215 units affected

  On certain vehicles that had the driver’s and/or front passenger's seat belt buckle replaced, a switch within the replacement buckle may incorrectly signal that the seat belt is always buckled. In the event of a crash, this may cause the airbag system not work as designed, and could increase the risk of injury to the occupant(s). Correction: Dealers will inspect the signal from the seat belt switch and replace the inner seat belt assembly as needed.

• Electrical#2017363July 20, 2017

  39,189 units affected

  On certain vehicles, the electrical power cords of some dealer installed block heaters may have been improperly manufactured, causing the wires to contact each other, resulting in a short circuit. A short circuit could lead to a fire which would increase the risk of injury and/or damage to property. Correction: For vehicles where the subject block heater was approved for installation, the dealer will replace the block heater assembly with a new one of an improved design. For vehicles where the subject block heater was not approved for installation, dealers will remove the block heater assembly. In the interim, until the remedy can be performed, dealers will cut the plug end from the block heater cord to disable the block heater's operation.

• Airbag#2016160April 13, 2016

  1,205 units affected

  Certain vehicles may not comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 208 - Occupant Protection in Frontal Impacts. The front passenger seat's occupant classification system (OCS) may not have been calibrated properly during the manufacturing process. This could result in the non-deployment of the front passenger air bag and the front passenger knee airbag, which would increase the risk of injury to the seat occupant in a crash where airbag deployment is warranted. Correction: Dealers will re-calibrate the occupant classification system.

• Brakes#2015521November 3, 2015

  6,274 units affected

  On certain vehicles equipped with Pre-Collision System (PCS), the system could unexpectedly activate while operating the vehicle. Under certain situations, the system may interpret a steel joint or plate in the roadway as an obstacle, and the system may apply the service brake automatically. If the PCS applies unexpected braking force during normal vehicle operation when no impending collision object is present, it could increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will disable the Pre-Collision System (PCS) as an interim measure, and when parts become available, will replace the PCS components with improved parts.

• Electrical#2015038January 28, 2015

  1,285 units affected

  On certain vehicles equipped with a trunk-mounted sub-woofer, cargo in the trunk could contact the sub-woofer's soft braided wire, which could cause the wire to move out of its normal position. If one of these wires were to come into contact with the metal frame of the sub-woofer, it could result in an intermittent short, causing the integrated circuit (IC) in the audio amplifier to become damaged. In some cases, the damaged IC could create a closed circuit between the power supply and sub-woofer, and electric current could continue to flow to the sub-woofer. If this were to occur, the sub-woofer could overheat, increasing the risk of fire, causing injury and/or damage to property. Correction: Dealers will replace the audio system amplifier and install a protective cover around the subwoofer. In the interim, dealers will disconnect the rear sub-woofer.

• Fuel System#2014409September 18, 2014

  1,422 units affected

  On certain vehicles, the end cap on the right-hand side fuel delivery pipe, located in the engine compartment, could have been improperly welded at time of manufacture. This could result in a fuel leak which, in the presence of an ignition source, could result in a fire causing injury and/or property damage. Correction: Dealers will inspect the fuel delivery pipe and replace with a revised part if necessary.

• Airbag#2013359October 17, 2013

  44,041 units affected

  On certain vehicles, if the air conditioning condenser drain hose were to become clogged, water could accumulate and leak onto the airbag control module. This could cause the airbag warning light to illuminate, and potentially result in an unintended deployment of the airbags. This could startle the driver and/or cause minor injuries to vehicle occupants. Water damage could also cause a loss of power steering assist, causing the vehicle to revert to a manual steering mode which would require greater driver effort, especially at low vehicle speeds, and increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will install a protective shield and sealant.

• Electrical#2013352October 10, 2013

  625 units affected

  On certain vehicles, the windshield wiper switch may have been manufactured incorrectly and could cause an electrical short when the wiper switch is moved from the OFF position to the MIST position. This would blow the fuse, causing the windshield wipers to become inoperative, potentially reducing driver visibility and increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace the switch.

• Other#2010012January 22, 2010

  273,050 units affected

  On certain vehicles, accelerator pedal movement may become rough, slow to return, or the pedal may stick in a depressed position. This could result in a loss of throttle control and a vehicle crash, causing property damage, personal injury or death. Correction: Dealers will install a steel reinforcement bar to the accelerator pedal assembly. With this reinforcement in place, the excess friction that can cause the pedal to stick is eliminated.

• Other#2009290October 7, 2009

  437,445 units affected

  On certain vehicles, the accelerator pedal may become stuck in the wide open position due to an unsecured or incompatible driver's floor mat. A stuck open accelerator pedal may result in very high vehicle speeds and make it difficult to stop the vehicle, which could cause a crash, serious injury or death. Correction: Dealers will reconfigure the shape of the accelerator pedal. Certain models will also have the shape of the floor underneath the accelerator pedal modified and/or a brake override system installed.

Canadian data updated August 24, 2026