2021 Tiffin Phaeton recalls

• Accessories#2022380July 20, 2022

  48 units affected

  Issue: On certain motorhomes, the service valve (main shutoff) for the propane tank may be defective. As a result, the connector may not seal properly and could leak propane. Safety Risk: A propane gas leak could create the risk of a fire or explosion. Corrective Actions: Tiffin will notify owners by mail and instruct you to take your motorhome to a dealership to perform a leak test and inspect the date code on the service valve. It will be replaced, if necessary. Tiffin recommends that you should shut off the service valve (main shutoff) on the propane tank until your motorhome is inspected.

• Lights And Instruments#2022378July 19, 2022

  22 units affected

  Issue: Under certain conditions, the tire pressure monitoring system (TPMS) may not display the current tire pressure and temperature on the instrument panel's information center. Instead, it could incorrectly display a temperature and pressure that is much higher than the normal range. This could cause confusion about the actual tire pressure. Driving a vehicle with tires that are not properly inflated could cause poor handling and/or a tire failure. Note: The TPMS warning telltale will continue to function as designed and will alert you if the tire pressure is too low. This recall only affects motorhome chassis equipped with a SpartanLync tire pressure monitoring system. This recall is part of FL-935 (Transport Canada recall 2022-276). Safety Risk: Poor handling or a tire failure could cause a loss of control and increase the risk of a crash. Corrective Actions: Tiffin will notify owners by mail and instruct you to take your vehicle to a Daimler Truck North America (DTNA) authorized service facility to update the TPMS control module software. Additionally, a longer TPMS antenna mounting bracket will be installed on certain motorhomes.

• Lights And Instruments#2022007January 13, 2022

  122 units affected

  Issue: Certain motorhomes built on a Freightliner chassis could have a problem with the rear-mounted Power Distribution Module (PDM). This could cause the tail lights not to work properly. Note: This recall replaces FL-856 (Transport Canada recall 2020-421). Motorhomes that were repaired under that recall also require this repair. Safety Risk: Brake lights or turn signals that do not work could cause a following driver not to recognize that a vehicle ahead is braking or intends to turn. This could increase the risk of a crash. Corrective Actions: Tiffin will notify owners by mail and instruct you to contact a Daimler Trucks North America (DTNA) authorized service facility to schedule a repair. The service facility will install a new wiring harness bypass.

• Wheels#2021749December 10, 2021

  91 units affected

  Issue: On certain motorhomes, the tire valve stem extensions for the inner wheels may get damaged by contact with the outer wheels. If this happens, the inner tire could lose air pressure. This could overload the outer tire and cause it to fail. Note: This recall replaces FL-861 (Transport Canada recall 2020-516). Motorhomes that were repaired under that recall also require this repair. Safety Risk: A tire failure could cause a loss of control and increase the risk of a crash. Corrective Actions: Tiffin will notify owners by mail and instruct you to take your motorhome to a Daimler Trucks North America (DTNA) authorized service facility to remove the inner valve stem extensions.

• Seats And Restraints#2021541September 1, 2021

  322 units affected

  Issue: On certain motorhomes, the seat belts on the sofas may not be properly installed. As a result, the seat belts may not work as designed in a crash. Safety Risk: A seat belt that does not work properly could increase the risk of injury in a crash. Corrective Actions: Tiffin will notify owners by mail and instruct you to take your motorhome to a dealer to inspect and repair the seat belts on the sofas, as necessary.

• Engine#2021451July 20, 2021

  13 units affected

  Issue: On certain motorhomes, the hoses between the fuel pump and remote fuel filter may be defective and could leak. Note: This recall only affects motorhomes equipped with a Cummins L9 diesel engine. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Tiffin and Cummins will notify owners by mail and instruct you to take your motorhome to a Cummins authorized service center to replace the fuel hoses.

• Fuel System#2021265May 4, 2021

  103 units affected

  Issue: On certain motorhomes, the fuel rail assembly could develop a leak. Note: This recall only affects motorhomes equipped with a Cummins L9 diesel engine. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Cummins will notify owners by mail and instruct you to take your motorhome to a Cummins authorized service center to inspect the fuel rail. If damage is found, the fuel rail and fuel lines will be replaced. If no damage is found, the fuel rail will be reassembled with new crush washers using a special tool.

Canadian data updated August 24, 2026

• EQUIPMENT:RECREATIONAL VEHICLE/TRAILER:LPG SYSTEMS#22V511000July 20, 2022

  Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2023 Allegro, Red 340, 2021-2022 Phaeton, Breeze, Allegro Red 360, and 2022 Bay motorhomes. The output line on the LPG tanks may not connect properly to the service valve, which can cause a propane leak.

  Risk: A propane leak in the presence of an ignition source can increase the risk of a fire.

  Remedy: Dealers will inspect and replace the service valves, as necessary, free of charge. Owner notification letters were mailed September 18, 2022. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-124.

• SEAT BELTS:REAR/OTHER:ANCHORAGE#21V680000November 5, 2021

  Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro Breeze, Allegro Red, Allegro, Allegro Bus, Phaeton, and 2018-2021 Zephyr recreational vehicles. The sofa seat belts may not have been installed correctly, which could result in unsecured passengers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."

  Risk: Unsecured passengers have an increased risk of injury in the event of a crash.

  Remedy: Dealers will inspect and repair the seat belts as necessary, free of charge. Owner notification letters were mailed October 29, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-118.

• ELECTRICAL SYSTEM:WIRING#21V783000October 7, 2021

  Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2022 Phaeton recreational vehicles. During manufacturing, an electrical outlet was not installed as intended, resulting in an open electrical wire inside the wall.

  Risk: An open electrical wire can increase the risk of a fire.

  Remedy: Dealers will inspect the vehicle and install an outlet on the wire, free of charge. Owner notification letters were mailed October 27, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-119.

• FUEL SYSTEM, DIESEL:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS#21V545000July 20, 2021

  Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021-2022 Allegro Bus and Phaeton motorhomes, equipped with certain Cummins L9 diesel engines. A fuel leak may occur from the fuel hose between the fuel pump and remote filter head.

  Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

  Remedy: Dealers will replace the fuel hoses, free of charge. Owner notification letters were mailed September 10, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-117.

• FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL#21V306000April 30, 2021

  Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2017-2021 Bus and Phaeton vehicles. The sealing washer may not seat correctly in the pilot bore, allowing the high pressure fuel rail assembly to leak.

  Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.

  Remedy: Tiffin will work with Cummins to inspect the rail threads , and replace the rail and fuel lines if damage is found, free of charge. Owner notification letters were mailed August 11, 2021. Owners may contact Tiffin customer service at 1-256-356-8661.

• STRUCTURE:BODY:ROOF AND PILLARS#21V265000April 15, 2021

  Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021 Phaeton motorhomes, equipped with a roof mounted passenger side awning. A roof mounted body panel may have been improperly attached to the roof.

  Risk: The roof mounted body panel may detach and become a road hazard, increasing the risk of a crash.

  Remedy: Tiffin will notify owners, and dealers will inspect and, if necessary, properly adhere the body panel, free of charge. Owner letters were mailed April 26, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-115.

• TIRES:VALVE#21V193000March 18, 2021

  Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2021 Phaeton recreational vehicles. The valve stem stabilizer can become loose, allowing the valve stem extender to contact the wheel.

  Risk: If the valve stem extender rubs on the wheel, it can cause a loss of tire pressure, increasing the risk of a crash.

  Remedy: Tiffin will notify owners, and dealers will replace the valve stem stabilizer, free of charge. The recall began April 22, 2021. Owners may contact Tiffin customer service at 1-256-356-8661. Tiffin's number for this recall is TIF-114.