Does the 2019 Thomas Built SAF-T-Liner C2 School BUS have any recalls?

Transport Canada lists 9 campaigns and the U.S. NHTSA lists 0 for the 2019 Thomas Built SAF-T-Liner C2 School BUS. Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.

How do I know if a recall applies to my 2019 Thomas Built SAF-T-Liner C2 School BUS?

Recalls are matched by make, model and model year, but many cover only certain VIN ranges. Confirm with your manufacturer or dealer using your full VIN, or use the official Transport Canada or NHTSA lookup.

Are recall repairs free?

Yes. In both Canada and the United States the manufacturer must fix a recalled defect at no charge, through a franchised dealer.

RECALLS — MAKE · MODEL · YEAR

2019 Thomas Built SAF-T-Liner C2 School BUS recalls

9 safety recall campaigns have been filed for the 2019 Thomas Built SAF-T-Liner C2 School BUS with Transport Canada and the U.S. NHTSA. Here is what both agencies say.

Canadian recalls: 09
U.S. recalls: 00
Total campaigns: 09

Transport Canada recalls

Label#2024423July 24, 2024
1,382 units affected
Issue: On certain school buses, the letters on the instruction labels for the emergency exits are too small. This could make it difficult to read the label. Canadian regulations require a minimum size for the letters. Safety Risk: Instructions for an emergency exit that are difficult to read could delay persons from exiting the bus in an emergency and increase the risk of injury. Corrective Actions: Daimler Truck North America (DTNA) will notify owners by mail and advise you to take your school bus to a DTNA authorized service facility to increase the height of the letters on the instruction labels.
Structure#2023540October 3, 2023
1,892 units affected
Issue: On certain school buses, the fasteners for the rear emergency exit door latch could loosen and detach. If this happens, and the door is pushed, it could open suddenly. Safety Risk: An emergency exit door that opens suddenly could increase the risk of injuries. Corrective Actions: Daimler Truck North America (DTNA) will notify owners by mail. The corrective actions for this recall are under development. DTNA recommends that you should contact them immediately if you notice any missing bolts during your daily pre-trip inspection.
Seats And Restraints#2019497October 4, 2019
4,355 units affected
Issue: This recall affects certain school buses equipped with SynTec S3B and/or S3C passenger seats. On some seats, the protective foam in certain areas of the seatback may not meet the knee impact requirements of Canadian regulations. Safety Risk: A seatback that does not have proper knee impact protection could increase the risk of injury to occupants in a crash. Corrective Actions: The company will notify owners by mail and instruct them to take their vehicle to a Daimler Trucks of North America authorized service facility to install additional protective material in the seatbacks.
Structure#2019362July 24, 2019
149 units affected
Issue: On certain school buses, the outer handle for the roof hatch (emergency exit) could break. If this happens, it would be difficult to open the roof hatch from outside the bus. Safety Risk: An emergency exit that is difficult to open could increase the risk of injury in an emergency. Corrective Actions: The company will notify owners by mail and instruct them to take their vehicle to a Daimler Trucks North America authorized service facility to replace the roof hatch outer handle.
Brakes#2019288June 12, 2019
80 units affected
Issue: A problem with the left-rear brake caliper on certain school buses may cause the brake pads to drag and overheat. This could result in high temperatures, smoke, odour, or a possible fire. Safety Risk: A fire could increase the risk of injury. This could also result in an emergency evacuation of a school bus in an uncontrolled environment, which could also increase the risk of an injury. Corrective Actions: The company will notify owners by mail and instruct them to take their vehicle to a Daimler Trucks North America authorized service facility to replace the left-rear brake caliper.
Electrical#2018735December 21, 2018
423 units affected
On certain school buses, if a short circuit or overload were to occur on the auxiliary port circuit, it could blow the fuse for the ignition circuit. This could result an engine stall without the ability to restart, increasing the risk of a crash causing injury and/or damage to property. Correction: Daimler Trucks of North America Authorized Service Facilities will modify vehicle wiring to ensure that the power port circuit does not affect the ignition circuit.
Steering#2018720December 20, 2018
4 units affected
On certain school buses, the bolts that join the steering and tie rod arm to the steering knuckle may not have been properly tightened. This could lead to a separation of the tie rod arm and cause a loss of steering control. This could create a risk of a crash causing injury and/or property damage. Correction: Daimler Trucks North America Authorized Service Facilities will inspect the steering and tie rod arm bolts to ensure they are torqued correctly and install new fasteners as necessary.
Structure#2018691December 11, 2018
507 units affected
On certain school buses, the roof header joints may be improperly bonded due to adhesive not being applied in the correct locations. In the event of a rollover crash, the structure of the vehicle could be affected, increasing the risk of injury to occupants. Correction: Daimler Trucks of North America Authorized Service Facilities will inspect the placement of the roof header adhesive and mechanical fasteners will be added to secure the joints as necessary.
Structure#2018448August 24, 2018
13 units affected
On certain school buses equipped with a Ricon S-Series or K-Series titanium wheelchair lift, the lift positioning input cam may fail. If this happens and the operator continues to press the "up" button, the platform could travel past the vehicle floor height, potentially causing a lift occupant to be tipped inwards toward the vehicle, which could increase the risk of injury. Correction: a Ricon authorized dealer will perform the repairs.

Canadian data updated August 24, 2026

U.S. NHTSA recalls

No recalls found for this make, model, and year.

Does this recall apply to my vehicle?

Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.

What to do

Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, or to book the work, contact your manufacturer or dealer with your full VIN, or use the official channel:

NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
Defects and recalls database — Transport Canada

Check a 2019 Thomas Built SAF-T-Liner C2 School BUS VIN

A VIN decode confirms your vehicle's exact model year, trim and assembly plant, then runs this same recall check against it.

Data sources and coverage limits →