2016 KIA Sorento recalls

• Label#2024549August 15, 2024

  647,384 units affected

  Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safety Risk: These small errors do not affect vehicle safety. Corrective Actions: This is not a recall. Kia has corrected the compliance label for all new vehicles.

• Lights And Instruments#2023449August 11, 2023

  49,277 units affected

  Issue: On certain vehicles, wear inside the multi-function switch could cause the headlights to turn off suddenly when the switch is in the AUTO mode. Safety Risk: A loss of headlights would reduce visibility and could increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and advise you to take your vehicle to a dealership to replace certain parts in the multi-function switch. To reduce the safety risk, Kia recommends not to use the AUTO mode until the recall repairs have been completed.

• Powertrain#2022453August 10, 2022

  3,540 units affected

  Issue: On certain vehicles, a problem with the transmission shifter assembly may allow you to shift out of the Park position (P) without pressing the brake pedal. If the transmission is shifted without applying the brakes and the parking brake isn't used, the vehicle could move suddenly or roll away. Safety Risk: A vehicle that moves suddenly or that rolls away could create the risk of an injury or a crash. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealership to inspect the shift lever assembly. The shift lock lever and holder will be replaced, if necessary. To reduce the safety risk, Kia recommends that you should always use the parking brake when you park.

• Electrical#2021680November 5, 2021

  9,612 units affected

  Issue: Certain vehicles may be equipped with an accessory trailer wiring harness that could fail. Over time, water could leak into the control module and cause a short circuit. If this happens, there could be loss of the trailer lights. Note: This recall affects trailer wiring harness kits that may have been ordered at the time of a vehicle purchase, or purchased separately from a dealer as an aftermarket accessory. Safety Risk: A loss of trailer lights could make the trailer less visible. In addition, other drivers may not recognize that the vehicle ahead is braking or intends to turn. This could increase the risk of a crash. Corrective Actions: Kia will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the trailer wiring harness. If the harness is from the lot (batch) affected by this problem, the dealer will replace it. Kia recommends that you should always check to ensure that trailer lights work properly before towing.

• Engine#2019143March 18, 2019

  79,301 units affected

  Issue: Kia Canada is conducting a Product Improvement Campaign that provides an update to the engine control module to detect potential problems before an engine fails. An engine failure may cause a sudden loss of power with an inability to restart. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to update the software for the engine control module. Note: Vehicles repaired under Service Campaign SC023 already have this software update.

• Fuel System#2019098February 27, 2019

  760 units affected

  Issue: When the engine was replaced under warranty or under Kia's Product Improvement Campaign SC023, the high pressure fuel pipe may not have been properly installed on the fuel pump outlet. A fuel leak could occur if the pipe was damaged, misaligned or improperly torqued during the recall repair. Safety Risk: Leaking fuel in the presence of an ignition source could increase the risk of a fire. Corrective Actions: The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer for an inspection. If fuel leakage is detected, the fuel pipe will be replaced with a new one.

• Seats And Restraints#2016540November 1, 2016

  453 units affected

  On certain vehicles, the driver’s seatback may have been incorrectly welded at time of assembly. This could cause the seatback to fail in a rear-end collision, increasing the risk of injury to vehicle occupants. Correction: Dealers will inspect the seat back frame and replace if necessary.

• Structure#2016346July 5, 2016

  1,286 units affected

  On certain vehicles, the rear crossmember assist arm bracket may not have been properly welded during the manufacturing process. This could cause the welds to break and affect the rear suspension alignment, which would result in poor vehicle handling, increasing the risk of a crash causing injury and/or damage to property. Correction : Dealers will inspect and replace the rear crossmember assembly as necessary.

Canadian data updated August 24, 2026

• TRAILER HITCHES#22V703000September 19, 2022

  Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

  Risk: A fire while parked or driving can increase the risk of injury.

  Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.

• POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT#22V612000August 10, 2022

  Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway.

  Risk: A vehicle rollaway increases the risk of a crash and injury.

  Remedy: Dealers will inspect and replace the automatic transmission shift lever assembly components, as necessary, free of charge. Owner notification letters were mailed October 7, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC246.

• FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS#18V907000December 19, 2018

  Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

  Risk: A fuel leak in the presence of an ignition source can increase the risk of a fire.

  Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

• TRAILER HITCHES#16V862000November 30, 2016

  Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."

  Risk: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.

  Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.

• SEATS#16V770000October 24, 2016

  Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured March 3, 2016 to March 21, 2016. The driver's seatback frame may have been produced with inadequate weld joints and, as a result, the seatback may not function as designed in the event of a rear-end collision.

  Risk: In the event of a crash, the driver seatback frame could break and fail to restrain a seat occupant, increasing the risk of injury.

  Remedy: Kia will notify owners, and dealers will inspect the welds and replace the driver seatback frame, as necessary, free of charge. The recall began on December 9, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC140.

• SUSPENSION:REAR#16V480000June 29, 2016

  Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles. A component of the rear suspension may not be properly welded.

  Risk: The improper weld may break, affecting the rear suspension alignment, thereby increasing the risk of a crash.

  Remedy: Kia will notify owners, and dealers will inspect the welds at the rear suspension cross-member, replacing the rear cross-member assembly, as necessary, free of charge. The recall began July 27, 2016. Owners may contact Kia Customer Service Department at 1-800-333-4542. Kia's number for this recall is SC137.

• SEAT BELTS:FRONT:BUCKLE ASSEMBLY#15V446000July 14, 2015

  Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured October 23, 2014, to December 10, 2014. The affected vehicles have a front passenger seat belt whose buckle latch assembly may prevent the front passenger from fastening the seat belt.

  Risk: If the front passenger seat belt cannot be latched, an occupant sitting in the front passenger seat has an increased risk of injury in the event of a crash.

  Remedy: Kia will notify owners, and dealers will replace the front passenger seat belt buckle cover, free of charge. The recall began on August 18, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC123.

• VEHICLE SPEED CONTROL:ACCELERATOR PEDAL#15V089000February 13, 2015

  Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles manufactured October 27, 2014, to January 29, 2015. Due to an improperly soldered component in the accelerator pedal assembly, the driver may not be able to accelerate the vehicle.

  Risk: If the vehicle is unable to be accelerated, there is an increased risk of a crash.

  Remedy: Kia will notify owners, and dealers will replace the accelerator assembly, free of charge. The recall began on February 19, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC115.