2020 Hyundai Kona recalls

• Other#2025636November 17, 2025

  332,486 units affected

  Issue : Hyundai Auto Canada is conducting an extended warranty campaign for certain vehicles as water could enter the horn assembly and cause the horn's electrical contacts to corrode. As a result, the horn may not work properly or at all. Safety risk: A horn that doesn't work properly could prevent a driver from warning others of a danger and create an unsafe situation. Corrective Actions: To reduce the safety risk, Hyundai advises you to test the horn regularly. Hyundai will notify owners in writing and advise you to contact a dealership if your horn doesn't work properly. Hyundai will provide an extended warranty of 10 years/200 000 km to replace the horn for free if it fails.

• Label#2024552September 23, 2024

  824,695 units affected

  Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safety Risk: These small errors do not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the compliance label for all new vehicles.

• Engine#2021252April 28, 2021

  76,192 units affected

  Issue: On certain vehicles, the engine's piston oil rings may be defective. This can cause engine wear that can lead to increased oil consumption. Eventually, this can create abnormal engine noise and the oil pressure warning light may turn on. If you continue to drive the vehicle with these symptoms, the engine could fail. Note: This only affects vehicles equipped with a 2.0 L Nu MPI engine. Safety Risk: A sudden loss of engine power could increase the risk of a crash. An engine failure could also create the risk of a fire. Corrective Actions: Hyundai will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the engine. The engine will be replaced, if necessary. Hyundai is also developing a Piston-ring Noise Sensing System (PNSS) software update to be installed when available; it will alert the driver of potential damage before an engine failure occurs.

• High Voltage#2021109March 1, 2021

  3,558 units affected

  Issue: On certain electric vehicles, there could be a problem inside the high-voltage battery. As a result, the high-voltage battery could short circuit while the vehicle is parked, charging, or driving. Note: Vehicles that had a battery replacement after completion of Hyundai recall R0175 (Transport Canada Recall No. 2020-477) do not require repair under this recall. For the Hyundai Ioniq, only certain all-electric models are affected by this recall. Safety Risk: A short circuit in the battery could cause a fire. Corrective Actions: Hyundai will notify owners by mail and instruct you bring your vehicle to a dealer to lower the battery charging limit to 80% until the final repair is available. You will also be provided with instructions for how to do this yourself using the vehicle's infotainment system. Hyundai recommends that you should park your vehicle outdoors, and away from other vehicles or buildings until the battery charging limit is changed. The second step of this recall will be to replace the high-voltage battery (BSA). Hyundai will notify you when a replacement battery is available for your vehicle. <a href=https://www.r0183info.ca/>Click here for more information. </a>

• Brakes#2020593December 2, 2020

  10,794 units affected

  Issue: On certain vehicles, an abnormal sensor signal to the Integrated Electronic Brake (IEB) system could cause a sudden reduction in braking performance. If this happens, a brake warning light will turn on in the instrument cluster. Safety Risk: Reduced brake performance can cause extended stopping distances and increase the risk of a crash. Corrective Actions: Hyundai will notify owners by mail and instruct you to take your vehicle to a dealer to update the IEB system software.

• High Voltage#2020477October 13, 2020

  4,375 units affected

  Issue: On certain vehicles, there could be problems with the high-voltage battery that cannot be detected by the battery management system (BMS). As a result, the high-voltage battery could short circuit after it is fully charged. Safety Risk: A short circuit in the battery could cause a fire. Corrective Actions: Hyundai will notify owners by mail and instruct you to take your vehicle to a dealer for an inspection. The high-voltage battery will be replaced, if necessary. The dealer will also update the BMS software to better detect battery problems. Hyundai recommends that you should park your vehicle outdoors, and away from other vehicles or buildings until the recall repairs are completed.

• Label#2020016January 20, 2020

  529 units affected

  Issue: The compliance label on certain vehicles lists an incorrect Gross Axle Weight Rating (GAWR). This could lead to overloading of the vehicle and cause poor handling or a tire failure. Safety Risk: Poor handling or a tire failure could cause a loss of control and result in a crash. Corrective Actions: Hyundai will notify owners by mail and instruct you to take your vehicle to a dealer to install a label providing the correct GAWR.

Canadian data updated August 24, 2026

• ENGINE#21V301000April 28, 2021

  Hyundai Motor America (Hyundai) is recalling certain 2019-2020 Elantra, 2019-2021 Kona and Veloster vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which could result in engine damage.

  Risk: A damaged engine may stall, increasing the risk of a crash. In addition, oil may leak onto hot exhaust components, increasing the risk of a fire.

  Remedy: Dealers will inspect and, if necessary, replace the engine, free of charge. In addition, Hyundai will deploy Piston Ring Noise Sensing System (PNSS) software. Owner notification letters were mailed August 24, 2021. Owners may contact Hyundai customer service at 1-855-371-9460.

• EQUIPMENT:OTHER:LABELS#20V022000January 17, 2020

  Hyundai Motor America (Hyundai) is recalling certain 2020 Kona vehicles. The certification label may indicate incorrect Gross Axle Weight Rating (GAWR). As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 567, "Certification" and 110, "Tire Selection and Rims."

  Risk: An incorrect GAWR could result in the vehicle being overloaded, increasing the risk of a crash.

  Remedy: Hyundai will notify owners, and dealers will install new label stickers displaying the correct GAWR over the affected areas of the certification label, free of charge. The recall began March 2, 2020. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 187.