2024 GMC Sierra 3500 recalls

• Structure#2025350June 25, 2025

  41,113 units affected

  Issue: On certain trucks, water could leak into the exterior tailgate switch. As a result, the tailgate could unlatch and open unexpectedly while parked. If this happens, cargo that is not secured could fall out of the truck bed and onto the road when the vehicle is moving. Note: This recall only affects trucks equipped with a power-locking tailgate. This is an expansion of recall N232426400 (Transport Canada recall no. 2024-061). Safety Risk: Cargo that falls from the truck bed could create a road hazard for others and increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and advise you to take your truck to a dealership to replace the exterior tailgate switch. To reduce the safety risk, General Motors recommends that you should inspect the tailgate to ensure it's closed and latched before driving.

• Engine#2025225April 24, 2025

  49,848 units affected

  Issue: On certain vehicles, the connecting rods and/or crankshaft components may not have been manufactured properly. As a result, the engine could make abnormal noises and a warning light may turn on. If you continue to drive the vehicle with these symptoms, the engine could fail. Note: This recall only affects certain vehicles equipped with a 6.2 L V8 gas engine. Safety Risk: An engine failure could cause a sudden loss of power to the wheels and increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and advise you to take your vehicle to inspect and, if necessary, repair or replace the engine. For vehicles that pass the engine inspection, the dealer will replace the oil with a higher viscosity oil, install a new oil fill cap, replace the oil filter, and add an insert to the owner's manual.

• Lights And Instruments#2024060February 1, 2024

  273,306 units affected

  Issue: On certain vehicles, a software problem could cause the lower beam headlamps not to turn on as it becomes dark outside if the multi-function switch is in the "OFF" or "PARKING LAMP" position. This could also cause the daytime running lamps (DRLs) to turn off when the vehicle is moving. As a result, the vehicles may not meet certain requirements of Canadian regulations. Safety Risk: Headlamps and/or DRLs that don't turn on could reduce visibility, make the vehicle less visible to others and increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and advise you to take your vehicle to a dealership to update the body control module (BCM)software.

• Lights And Instruments#2023472August 24, 2023

  163,611 units affected

  Issue: On certain vehicles, the automatic headlamps may not turn on soon enough as it becomes dark outside. Canadian regulations require automatic headlamps to turn on when the ambient light level drops below a certain point (1000 lux). Safety Risk: Headlamps that don't turn on as it becomes dark outside could reduce visibility and increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the body control module (BCM) software. Alternatively, you may schedule an appointment to have the update performed at a GM dealership.

Canadian data updated August 24, 2026

• LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH#24V894000November 26, 2024

  General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado HD 2500, 3500, and GMC Sierra HD 2500, 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in Park.

  Risk: An unlatched tailgate may open and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

  Remedy: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed December 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N242469160. This recall is an expansion of NHTSA Recall 24V-060.

• LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH#24V060000February 1, 2024

  General Motors, LLC (GM) is recalling certain 2020-2024 Chevrolet Silverado 2500, 3500, GMC Sierra 2500 and 3500 vehicles equipped with power-unlatching tailgates. The tailgate's electronic gate-release switch may short circuit due to water intrusion, which can result in the tailgate inadvertently unlatching while the vehicle is in park.

  Risk: An unlatched tailgate may open while driving and result in a loss of unsecured cargo, creating a road hazard and increasing the risk of a crash.

  Remedy: Owners are advised to check that the tailgate is closed and latched before driving. Dealers will replace the exterior touchpad switch assemblies, free of charge. Owner notification letters were mailed May 17, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232426400.

• STEERING#23V549000August 3, 2023

  General Motors, LLC (GM) is recalling certain 2024 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles. The steering gear shaft may fracture and disconnect from the steering arm.

  Risk: A steering arm that disconnects may result in a total loss of steering control, increasing the risk of a crash.

  Remedy: Dealers will inspect and replace the steering gear, if necessary, free of charge. Owner notification letters were mailed September 22, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N232414720.