2017 GMC Sierra 2500 recalls

• Electrical#2024294May 24, 2024

  4,699 units affected

  Issue: On certain trucks, the repairs completed by a General Motors dealer during recall N192220470 (Transport Canada recall no. 2019-325) or customer satisfaction program no. N192270330 may not have been completed properly. As a result, a second repair is required. Additionally, certain trucks may not have had the updated parts installed during production. On certain trucks equipped with a power sliding rear window, the rear defroster wiring could overheat and melt. Safety Risk: Wiring that overheats and melts can create the risk of a fire. Corrective Actions: General Motors will notify owners by mail and advise you to take your truck to a dealership to replace the contact cover for the sliding rear window. The dealer will also update the heating, ventilation, and air conditioning (HVAC) software, if necessary. If the rear window or sliding glass assembly are damaged, they will be replaced.

• Brakes#2019533October 24, 2019

  37,378 units affected

  Issue: On certain vehicles, there may be an error in the electronic-brake control module software. This could cause the driveline-protection system to activate when a wheel-speed sensor fails. If this happens, the brakes could apply and cause the vehicle to pull to one side. Note: This recall only affects vehicles equipped with four-wheel drive, a 5.3-L engine, and a 3.08 ratio rear axle. The problem can only occur when the vehicle is in four-wheel drive or automatic mode, and travelling at a speed between 66 and 97 km/h (41 and 60 mph). A wheel-speed sensor failure will cause the electronic stability control (ESC) and anti-lock braking system (ABS) warning lights to turn on, and a "Service StabiliTrak" message to display. Safety Risk: A vehicle that suddenly pulls to one side could increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and instruct you to take your vehicle to a dealer to update the electronic-brake control module software. General Motors advises that using two-wheel-drive mode can eliminate the risk until the recall repair is completed.

• Other#2019420August 21, 2019

  5,327 units affected

  Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.

• Electrical#2019325June 28, 2019

  159,474 units affected

  Issue: On certain trucks equipped with a power sliding rear window, the rear defroster circuit could overheat. This could cause melting, smoke or, in rare instances, a fire. Safety Risk: A fire could create a risk of injury. Corrective Actions: The company will notify owners by mail and advise you to take your truck to a dealer to replace the covers for the buss bar and contacts for the rear sliding window. If the rear window or sliding glass assembly are damaged due to a problem with the rear defroster, they will also be replaced.

• Brakes#2019324June 28, 2019

  310,121 units affected

  Issue: On certain vehicles, there could be a reduction in power brake assist due to a decrease in output from the vacuum pump. This could cause a hard brake pedal and an increase in brake pedal effort to stop the vehicle. Safety Risk: A sudden increase in brake pedal force could lead to an increase in stopping distance. This could increase the risk of a crash. Corrective Actions: The company will notify owners by mail and instruct them to take their vehicle to a dealer to reprogram the electronic brake control module.

• Other#2017383August 3, 2017

  2,123 units affected

  Certain regular cab vehicles fail to comply with the requirements of Canada Motor Vehicle Safety Standard (CMVSS) 210.2 - Lower Universal Anchorage Systems for Restraint Systems and Booster Cushions. The owner’s manual may be missing written instructions for using the tether anchorages and child restraint anchorage systems in the vehicle, which is contrary to standard. Correction: Owners will be mailed owner’s manual inserts containing the information required by CMVSS 210.2. For unsold vehicles, dealers will include the insert to the manual prior to sale.

• Airbag#2016439September 9, 2016

  362,263 units affected

  On certain vehicles, the sensing and diagnostic module (SDM), which controls airbag and pretensioner deployment, contains a software defect which may prevent the deployment of frontal airbags and pretensioners in certain circumstances. Failure of frontal airbags and seatbelt pretensioners to deploy in a crash (when warranted) could increase the risk of injury. Correction: Dealers will reflash the SDM with new software. In vehicles with any previous deployment events recorded in the SDM, the dealers will replace the existing SDM with a new SDM containing the latest software. Note: This recall affects 2014-2017 model year Sierra LD/Silverado LD models and 2015-2016 model year Sierra HD/Silverado HD model vehicles.

Canadian data updated August 24, 2026

• FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY#23V047000February 2, 2023

  General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500, and GMC Sierra 2500, 3500 vehicles equipped with a dual fuel tank option. The rear fuel tank may collapse and prevent the fuel pump from transferring fuel to the front tank, resulting in an engine stall.

  Risk: An engine stall increases the risk of a crash.

  Remedy: Dealers will inspect the fuel tank and fuel pump module, replacing them as necessary. Dealers will also add a vent hose to the rear tank assembly. Repairs will be performed free of charge. An interim owner notification letter informing owners of the safety risk was mailed on March 15, 2023. Owner notification letters were mailed June 21, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is N222368030.

• EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER#21V496000July 1, 2021

  General Motors, LLC (GM) is recalling certain 2017-2019 Chevrolet Silverado 2500, 3500 and 2017-2019 GMC Sierra 2500 and 3500 vehicles equipped with a Duramax diesel 6.6 liter engine and an optional engine-block heater cord. An electrical short-circuit may occur in the engine-block heater cable or in the terminals that connect the heater cable to the block heater.

  Risk: An electrical short-circuit can increase the risk of a fire.

  Remedy: Dealers will replace engine block heaters and heater cords. Vehicles that have this feature disabled as a remedy to the safety condition will be contacted and offered replacement block heaters and heater cords under a separate customer satisfaction program, free of charge. GM will provide free replacement block heaters and cords under a separate customer satisfaction campaign. For vehicles previously included in recall 19V-328, the heater cord will be replaced and rerouted, free of charge. Interim owner notifications were mailed on August 13, 2021. Owner notification letters are expected to be mailed on April 4, 2022. Customers may call GMC customer service at 1-800-462-8782. GM's number for this recall is 212329840.

• ENGINE#19V328000April 25, 2019

  General Motors LLC (GM) is recalling certain 2019 Chevrolet Silverado 4500, 5500 and 6500 vehicles and 2017-2019 Chevrolet Silverado 2500 and 3500 vehicles and GMC Sierra 2500 and 3500 vehicles equipped with Duramax 6.6 liter diesel engines and an optional engine-block heater. The engine block heater cord or the terminals that connect the heater cord to the block heater may short circuit and fail.

  Risk: A short-circuit may damage the engine components and increase the risk of fire.

  Remedy: GM will contact owners, dealers will replace the engine block heater, free of charge. Additionally, in Chevrolet Silverado 2500 and 3500 vehicles, dealers will install a new rerouted heater cord. The recall began December 11, 2019. Owners may contact GM customer service at 1-586-596-1733. GM's number for this recall is N182206310.

• SEAT BELTS:FRONT:RETRACTOR#17V567000September 14, 2017

  General Motors (GM) is recalling certain 2017-2018 Chevrolet Silverado 2500 and 3500 and GMC Sierra 2500 and 3500 trucks. The front seat belt retractor assemblies were built with the incorrect torsion bar. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."

  Risk: The seat belt retractors may not perform as intended during a crash, increasing the risk of injury.

  Remedy: GM will notify owners, and dealers will replace both front seat belt retractor assemblies, free of charge. The recall began March 24, 2021. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's numbers for this recall are 17368, 17375, and 17376.

• AIR BAGS:FRONTAL#17V437000July 10, 2017

  General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

  Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

  Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.

• AIR BAGS:FRONTAL#16V651000September 8, 2016

  General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

  Risk: A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

  Remedy: GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.