2021 Ford Bronco Sport recalls

• Electrical#2026356July 20, 2026

  36,061 units affected

  Issue: On certain vehicles, the engine wiring harness may not have enough protection and could become damaged by contact with surrounding components. As a result, the wiring harness could short circuit. Safety Risk: A short circuit can create the risk of a fire. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to install additional protection on the engine wiring harness. The dealer will also repair or replace the engine wiring harness, as necessary.

• Suspension#2026259May 27, 2026

  815 units affected

  Issue: On certain vehicles, the front lower ball joint(s) may not have been installed correctly on the steering knuckle(s). As a result, the front lower ball joint(s) could separate and cause a loss of steering control. Safety Risk: A loss of steering control could create a risk of a crash. Corrective Actions: To reduce the safety risk Ford advises you not to drive your vehicle until the recall repairs are completed. Ford will notify owners by mail and advise you to contact a dealer to arrange for an inspection. The dealer will repair the front steering knuckle(s), as necessary.

• Structure#2026229May 12, 2026

  1,154 units affected

  Issue: On certain vehicles, the hard top roof panels may not have been manufactured properly. As a result, sections of the exterior panels could separate and detach from the vehicle while driving. Note: This recall only affects certain vehicles equipped with a molded-in-colour hard top. Safety Risk: A section of roof that detaches from the vehicle could create a hazard for others and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the hard top.

• Powertrain#2026188April 15, 2026

  302 units affected

  Issue: On certain vehicles, the transmission may not have been reassembled properly after service. As a result, the transmission output shaft splines and/or the transfer case input splines could wear and fail. If this happens, there could be a loss of power to the wheels, or the vehicle could move when it's parked and the parking brake isn't used. Safety Risk: A loss of power to the wheels could increase the risk of a crash. A parked vehicle that rolls away could create the risk of an injury or a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the transmission and transfer case.

• Visual System#2026093March 3, 2026

  81,850 units affected

  Issue: Under certain conditions, the infotainment system could overheat. As a result, the rearview camera image may not display when the transmission is shifted into reverse. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the APIM software. Alternatively, you may schedule an appointment to have the update performed at a Ford dealership.

• Electrical#2026005January 9, 2026

  138,783 units affected

  Issue: On certain vehicles, the engine block heater could leak coolant. If this happens, the block heater could short circuit when it's plugged in. Note: This recall replaces Transport Canada recall no. 2025-554. Vehicles that were repaired under that recall don't require this repair. Safety Risk: A short circuit can create the risk of a fire. Corrective Actions: To reduce the safety risk, Ford advises you not to use the engine block heater until the recall repairs have been completed. Ford will notify owners by mail and advise you to take your vehicle to a dealership to replace the block heater. Alternatively, owners can choose to have the dealership permanently disable the engine block heater.

• Seats And Restraints#2025585October 24, 2025

  10,978 units affected

  Issue: On certain vehicles, the pivot bolts in the height adjuster assembly for the front seats may not have been manufactured properly. As a result, the bolt(s) could loosen and detach. If this happens, the seat(s) could move in a crash. Safety Risk: A seat that moves in a crash could increase the risk of injury. Corrective Action: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the height-adjust link(s) and pivot bolts.

• Brakes#2025553October 11, 2025

  9,344 units affected

  Issue: Certain vehicles may not meet the minimum stopping requirements of Canadian regulations. In particular, the vehicle may have an extended stopping distance if there is a loss of power brake assist. Note: This recall does not affect vehicles with an electronic brake booster (EBB). This recall replaces Transport Canada recall no. 2021-727. Vehicles that were repaired under that recall don't require this repair. Safety Risk: Reduced braking could cause extended stopping distances and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to replace the front brake pads.

• Electrical#2025554October 10, 2025

  128,886 units affected

  This recall was replaced by Transport Canada recall no. 2026-005. Issue: On certain vehicles, the engine block heater could leak coolant. If this happens, the block heater could short circuit when it's plugged in. Safety Risk: A short circuit can create the risk of a fire. Corrective Actions: To reduce the safety risk, Ford advises you not to use the engine block heater until the recall repairs have been completed. Ford will notify owners by mail and advise you to take your vehicle to a dealership to replace the block heater.

• Engine#2025376July 14, 2025

  70,618 units affected

  Issue: On certain vehicles, a fuel injector may crack. If this happens, fuel could leak into the engine compartment. Note: This recall only affects vehicles equipped with a 1.5 L EcoBoost engine. This recall replaces Transport Canada recalls 2022-658, 2024-160 and 2025-134. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Ford will notify owners by mail. As an interim repair, a dealer will update the engine control software to detect fuel injector leaks. Owners that have already received this software update will be informed that the interim repair is not required. Once the final repair is available, Ford will notify owners by mail and advise you to take your vehicle to a dealership to replace the high-pressure fuel rail assembly, high-pressure fuel injectors, and update the engine control software.

• Fuel System#2025366July 8, 2025

  107,534 units affected

  Issue: On certain vehicles, the low-pressure fuel pump could fail. If this happens, the engine may run rough or may not start and the check engine light may turn on. This could also result in a sudden loss of engine power while driving. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the powertrain control module software. For Super Duty models, the dealer will replace the fuel pump.

• Visual System#2025360June 27, 2025

  16,575 units affected

  Issue: On certain vehicles, a software problem could cause the rearview camera image not to display when the transmission is shifted into reverse. Canadian regulations require the rearview image to display when the vehicle is reversing. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the SYNC software.

• Visual System#2025260May 9, 2025

  159,135 units affected

  Issue: On certain vehicles, a software problem could cause the rearview camera image not to display or to freeze when the transmission is shifted into reverse. Safety Risk: A rearview camera image that doesn't display correctly could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the SYNC software. Alternatively, you may schedule an appointment to have the update performed at a Ford dealership.

• Visual System#2025255May 9, 2025

  442 units affected

  Issue: On certain vehicles, the recall repairs completed by a Ford dealer during recall 22C27 (Transport Canada recall no. 2022-636) may not have been done correctly. As a result, a second repair is required. Under certain conditions when the vehicle is operated in 4WD-Low (4L) mode, the rearview camera image could reappear on the display after shifting out of reverse. Note: This recall only affects certain vehicles equipped with an 8-inch display. Safety Risk: A rearview camera image that displays when the vehicle is not in reverse may confuse or distract the driver. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and send a wireless over-the-air software update for the SYNC module to each vehicle. Alternatively, you may schedule an appointment to have the update performed at a Ford dealership.

• Visual System#2025223April 24, 2025

  25,260 units affected

  Issue: On certain vehicles equipped with a 360-degree camera, a software problem could cause the rearview camera image not to appear on the SYNC display screen. Canadian regulations require the rearview image to display when the vehicle is reversing. Note: This recall replaces Transport Canada recall no. 2023-477. Vehicles that were repaired under that recall don't require this repair. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to replace the rearview camera, and modify the camera wire retention as necessary. Some Transit models will also require a software update.

• Visual System#2025199April 11, 2025

  430 units affected

  Issue: On certain vehicles, the recall repairs completed by a Ford dealer during recall 23S48 (Transport Canada recall no. 2023-477) may not have been done correctly. As a result, a second repair is required. On certain vehicles equipped with a 360-degree camera, a software problem could cause the rearview camera image not to appear on the SYNC display screen. Canadian regulations require the rearview image to display when the transmission is shifted into reverse gear. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the rearview camera software.

• Electrical#2025139March 14, 2025

  4,159 units affected

  Issue: On certain vehicles, the recall repairs completed by a Ford dealer during recall 24S24 (Transport Canada recall no. 2024-224) may not have been done correctly. As a result, a second repair is required. On certain vehicles, the powertrain control module (PCM) and body control module (BCM) may not detect a change in the charge level of the 12 V battery. As a result, the engine could stall. This could also cause the engine not to restart after a start-stop event and the hazard lights may not work. Safety Risk: A sudden loss of power to the wheels or a vehicle that doesn't restart after a start-stop event could increase the risk of a crash. Additionally, hazard lamps that don't work could make the vehicle less visible and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the PCM and BCM software.

• Engine#2025134March 14, 2025

  3,241 units affected

  Issue: On certain vehicles, the recall repairs completed by a Ford dealer during recalls 22S73 (Transport Canada recall no. 2022-658) or 24S16 (Transport Canada recall no. 2024-160) may not have been done correctly. As a result, another repair is required. On certain vehicles, a fuel injector may crack. If this happens, fuel could leak into the engine compartment. Note: This recall only affects vehicles equipped with a 1.5 L EcoBoost engine. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the engine control software to detect fuel injector leaks. The dealer will also install a drain tube. Ford will also provide an extended warranty of 15 years/240 000 km to replace cracked injectors.

• Electrical#2025022January 17, 2025

  30,938 units affected

  Issue: On certain vehicles, the 12 V battery may be defective. As a result, the engine could stall. This could also cause the engine not to restart after a start-stop event and the hazard lights may not work. Safety Risk: A sudden loss of power to the wheels or a vehicle that doesn't restart after a start-stop event could increase the risk of a crash. Additionally, hazard lamps that don't work could make the vehicle less visible and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the 12 V battery.

• Suspension#2025020January 17, 2025

  8,895 units affected

  Issue: On certain vehicles, the mounting flange between the external reservoirs and the rear shock absorbers may corrode and fail. If this happens, the external reservoir(s) could detach from the vehicle. Note: This recall only affects certain vehicles equipped with Bilstein shock absorbers. Safety Risk: An external reservoir that detaches from the vehicle could create a hazard for other road users and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect the rear shock absorbers. The dealer will apply an anti-corrosion sealant and install a shield, or replace the shock absorbers, as necessary.

• Engine#2024492August 23, 2024

  11,821 units affected

  Issue: On certain vehicles, the intake valves may not have been manufactured properly. As a result, the valves could break and cause the engine to fail. Note: This recall only affects certain vehicles equipped with a 2.7L or 3.0L EcoBoost engine. This problem would cause the engine to run rough and the engine malfunction indicator lamp to turn on. Safety Risk: An engine failure could cause a sudden loss of power to the wheels and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the engine.

• Electrical#2024224April 12, 2024

  55,656 units affected

  Issue: On certain vehicles, the powertrain control module (PCM) and body control module (BCM) may not detect a change in the charge level of the 12 V battery. As a result, the engine could stall. This could also cause the engine not to restart after a start-stop event and the hazard lights may not work. Safety Risk: A sudden loss of power to the wheels or a vehicle that doesn't restart after a start-stop event could increase the risk of a crash. Additionally, hazard lamps that don't work could make the vehicle less visible and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the PCM and BCM software.

• Visual System#2023477August 28, 2023

  14,381 units affected

  This recall was replaced by Transport Canada recall no. 2025-223. Issue: On certain vehicles equipped with a 360-degree camera, a software problem could cause the rearview camera image not to appear on the SYNC display screen. Canadian regulations require the rearview image to display when the vehicle is reversing. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to replace the rearview camera, and modify the camera wire retention as necessary. Some Transit models will also require a software update.

• Seats And Restraints#2023294May 19, 2023

  13,765 units affected

  Issue: On certain vehicles, there may not be enough space between the side of the seat and the interior trim to reach the latch plate for the front seat belt. As a result, it may be difficult to use the seat belts. Note: This recall only affects 5-door models. Safety Risk: Not wearing a seat belt can increase the risk of injury in a crash. Corrective Actions: Ford will notify owners by mail and advise you to bring your vehicle to a dealership to install a sliding clip on each front seat belt. This clip will help to reposition the seat belt latch plate. The dealer will also provide an owner's manual update with instructions for how to use the sliding clip correctly.

• Visual System#2023129March 13, 2023

  95 units affected

  Issue: On certain vehicles, the software update that was installed by a Ford dealer during recall 22C27 (Transport Canada recall number 2022-636) may not be effective. As a result, a second repair is required. Under certain conditions when the vehicle is operated in 4WD-Low (4L) mode, the rearview camera image could reappear on the display after shifting out of reverse. Note: This recall doesn't affect vehicles that received an over-the-air software update for the SYNC module as a part of recall 22C27. Safety Risk: A rearview camera image that displays when the vehicle is not in reverse may confuse or distract the driver. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and send a wireless over-the-air software update for the SYNC module to each vehicle. Alternatively, you may schedule an appointment to have the update performed at a Ford dealership.

• Airbag#2022721December 15, 2022

  136 units affected

  Issue: On certain vehicles, the side-impact sensors may not be secured correctly. As a result, the side airbags may not work properly in a side-impact crash. Note: This recall only affects 4-door models. Safety Risk: An airbag that does not work properly could create an increased risk of injury in a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to inspect and, if necessary, secure the driver and passenger side-impact sensors.

• Fuel System#2022658November 19, 2022

  53,653 units affected

  This recall was replaced by Transport Canada recall no. 2025-376. Issue: On certain vehicles, a fuel injector may crack. If this happens, fuel could leak into the engine compartment. Note: This recall only affects vehicles equipped with a 1.5 L EcoBoost engine. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to update the engine control software to detect fuel injector leaks. The dealer will also install a drain tube. Ford will also provide an extended warranty of 15 years/240 000 km to replace cracked injectors.

• Visual System#2022636November 4, 2022

  3,200 units affected

  Issue: Under certain conditions when the vehicle is operated in 4WD-Low (4L) mode, the rearview camera image could reappear on the display after shifting out of reverse. Note: This recall only affects certain vehicles equipped with an 8-inch display. Safety Risk: A rearview camera image that displays when the vehicle is not in reverse may confuse or distract the driver. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and send a wireless over-the-air software update for the SYNC module to each vehicle. Alternatively, you may schedule an appointment to have the update performed at a Ford dealership.

• Structure#2022309June 10, 2022

  5,354 units affected

  Issue: On certain vehicles, the child safety lock on the right rear door may not work properly. As a result, the door could be opened from the inside of the vehicle when the safety lock is in the "ON" position. Safety Risk: A child safety lock that does not work properly could allow a child to open a rear door while the vehicle is moving, and create a risk of injury. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect, and if necessary, replace the rear door latch(es). Ford will also provide you with instructions for how to check the child safety locks before taking your vehicle to the dealership.

• Engine#2022152March 29, 2022

  36,486 units affected

  Issue: On certain vehicles equipped with a 1.5 L Ecoboost engine, the engine oil separator could leak. If this happens, oil could leak onto hot engine parts. Safety Risk: Oil that leaks onto hot engine parts could cause a fire. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to inspect the engine oil separator for damage and leaks. The oil separator and seals will be replaced, if necessary.

• Accessories#2021770December 17, 2021

  214 units affected

  Issue: On certain vehicles equipped with adaptive cruise control (ACC), there could be a problem with the front radar module. As a result, your vehicle may follow another too closely when using adaptive cruise control. Also, the pre-collision assist (PCA) system might not detect a possible crash and the application of automatic emergency braking (AEB) may be delayed. Safety Risk: Following too closely behind another vehicle could increase the risk of a crash. An automatic emergency braking (AEB) system that doesn't work properly may not reduce the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealer to adjust the angle of the cruise control radar module.

• Brakes#2021727November 26, 2021

  9,010 units affected

  This recall was replaced by Transport Canada recall no. 2025-553. Issue: Certain vehicles may not meet the minimum stopping requirements of Canadian regulations. In particular, the vehicle may have an extended stopping distance if there is a loss of power brake assist. Note: This recall does not effect vehicles with an electronic brake booster (EBB). Safety Risk: Reduced braking could cause extended stopping distances and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to replace the front brake pads.

• Structure#2021639October 18, 2021

  272 units affected

  Issue: On certain vehicles, the moonroof glass may not be properly attached to the frame. As a result, the glass could become loose and separate from the vehicle. Safety Risk: A glass moonroof that detaches from the vehicle could create a road hazard for others and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the date code of the moonroof glass. It will be replaced, if necessary.

• Airbag#2021609October 1, 2021

  58 units affected

  Issue: On certain vehicles, the passenger-front airbag may not have been folded properly. As a result, the airbag may not inflate properly in a crash. Safety Risk: An airbag that does not inflate properly could create an increased risk of injury in a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealer to replace the passenger-front airbag.

• Fuel System#2021508August 12, 2021

  2,398 units affected

  Issue: On certain vehicles, the fuel delivery module could leak inside the fuel tank. If this happens, low fuel pressure could cause the engine not to start, or it could stall while driving. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealer to replace the fuel delivery module.

• Suspension#2021082February 19, 2021

  24 units affected

  Issue: On certain vehicles, the bolts that attach the rear suspension module to the subframe may be loose or missing. As a result, vehicle stability and rear impact crash performance could be reduced. Safety Risk: Reduced stability could cause a loss of control and increase the risk of a crash. Reduced rear crash performance could create an increased risk of injury in a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the rear suspension module bolts. The bolts will be tightened or replaced, as necessary.

• Powertrain#2021011January 18, 2021

  33 units affected

  Issue: On certain vehicles, the rear drive unit was not properly filled with oil. As a result, the rear axle could seize. If this happens, the rear wheels could lock up and cause a loss of power to the wheels. Safety Risk: A rear-wheel lock up while driving could cause a loss of control that could result in a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a Ford or Lincoln dealer to check the oil level in the rear drive unit. If the drive unit is filled to the minimum oil level, it will be topped up to the full level. If the oil is below the minimum level, the drive unit will be replaced.

Canadian data updated August 24, 2026

• SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT#26V340000May 27, 2026

  Ford Motor Company (Ford) is recalling certain 2021-2026 Bronco Sport and 2022-2026 Maverick vehicles. The front lower control arm ball joints may have been incorrectly installed or incorrectly repaired at the vehicle assembly plant, allowing the control arm to disconnect from the front wheel knuckle.

  Risk: A detached control arm can cause a loss of vehicle control, increasing the risk of a crash.

  Remedy: Owners are advised not to drive their vehicles until the remedy is completed. Dealers will inspect and repair the front lower control arm ball joints as necessary, free of charge.Owner notification letters were mailed September 2, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S36. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 29, 2026.

• EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER#25V685000October 10, 2025

  Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

  Risk: An electrical short circuit can increase the risk of a fire.

  Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

• FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM#25V467000July 11, 2025

  Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

  Risk: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.

  Remedy: Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.

• BACK OVER PREVENTION:SOFTWARE#25V442000June 27, 2025

  Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.

  Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.

  Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.

• POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)#25V158000March 14, 2025

  Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles previously repaired incorrectly under recall number 24V-267. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

  Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

  Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed April 23, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S26.

• FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM#25V165000March 14, 2025

  Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.

  Risk: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

  Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.

• ELECTRICAL SYSTEM:12V/24V/48V BATTERY#25V019000January 17, 2025

  Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco Sport and 2022-2023 Maverick vehicles. The 12-volt battery may experience degradation and suddenly fail.

  Risk: Battery failure can result in a loss of electrical accessories, including the hazard lights, or cause a loss of drive power, increasing the risk of a crash.

  Remedy: Dealers will inspect and if necessary, replace the 12-volt battery, free of charge. Owner notification letters were mailed May 2, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S02. Vehicles in this recall were previously repaired under 24V-267 and will need to have the new remedy completed.

• ELECTRICAL SYSTEM:BODY CONTROL MODULE/BCM#24V267000April 12, 2024

  Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2022-2023 Maverick vehicles. The body and power train control modules may fail to detect a change in the 12-volt battery state of charge.

  Risk: An undetected low battery charge can result in a loss of electrical accessories such as hazard lights, or cause a loss of drive power, increasing the risk of a crash.

  Remedy: Dealers will recalibrate the body control module and power train control module, free of charge. Owner notification letters were mailed on June 4, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S24.

• FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM#22V859000November 18, 2022

  Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.

  Risk: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

  Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.

• ENGINE AND ENGINE COOLING:ENGINE:OIL/LUBRICATION#22V191000March 25, 2022

  Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.

  Risk: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.

  Remedy: Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.

• SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:CALIPER#21V922000November 23, 2021

  Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco Sport and Escape vehicles. The rear brake linings may have been manufactured incorrectly, which can affect braking performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

  Risk: During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.

  Remedy: Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31.

• VISIBILITY:SUN/MOON ROOF ASSEMBLY#21V809000October 15, 2021

  Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. The moonroof glass may not have been bonded correctly to the moonroof frame, which could result in the glass panel detaching from the vehicle.

  Risk: A detached glass panel can become a road hazard, and increase the risk of a crash or injury.

  Remedy: Dealers will inspect the moonroof glass date code and replace the glass, if necessary, free of charge. Owner notification letters were mailed November 18, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S46.

• FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP:CONTROL/DRIVE MODULE#21V625000August 10, 2021

  Ford Motor Company (Ford) is recalling certain 2021 Escape, Lincoln Corsair, and 2021-2022 Bronco Sport vehicles. The fuel delivery module may leak inside the fuel tank, causing low fuel pressure which could result in an engine stall.

  Risk: An engine stall increases the risk of a crash.

  Remedy: Dealers will replace the fuel delivery module, free of charge. Interim notification letters (remedy not available) were mailed on September 30, 2021. Owner notification letters were mailed on December 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S38.

• SUSPENSION:FRONT:CONTROL ARM#21V074000February 16, 2021

  Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. These vehicles may have been produced with incorrect front lower control arms.

  Risk: An incorrect lower control arm may affect vehicle handling and control, increasing the risk of a rollover crash.

  Remedy: Ford will notify owners, and dealers will inspect and replace the front lower control arms, if necessary, free of charge. The recall began April 9, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S03.

• SUSPENSION:REAR#21V075000February 16, 2021

  Ford Motor Company (Ford) is recalling certain 2021 Bronco Sport vehicles. The rear suspension subframe assembly may have loose or missing bolts.

  Risk: Loose or missing bolts may affect the vehicle's handling and control, increasing the risk of a crash. It could also reduce the vehicle's performance in a rear impact crash, increasing the risk of injury.

  Remedy: Ford will notify owners, and dealers will inspect the rear suspension bolts, and secure or replace the bolts, as necessary, free of charge. The recall began March 10, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S04.

• POWER TRAIN:DRIVELINE:DRIVESHAFT#21V011000January 15, 2021

  Ford Motor Company (Ford) is recalling certain 2020-2021 Edge, 2020 Lincoln Nautilus and Ford Escape and 2021 Lincoln Corsair and Ford Bronco Sport vehicles. An inadequate amount of lubricant in the rear drive unit may cause seizure of the rear drive axle.

  Risk: If the rear drive unit seizes, there may be a loss of drive and/or a loss of vehicle control, increasing the risk of a crash.

  Remedy: Ford will notify owners, and dealers will check the rear drive unit lubricant level. Axles found to have lubricant at the minimum level will be filled to the full level. Axles found to be below the minimum lubricant fill level will be replaced, free of charge. This recall began March 12, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S02.