RECALLS — MAKE · MODEL · YEAR
2017 E-ONE Quest II recalls
7 safety recall campaigns have been filed for the 2017 E-ONE Quest II with Transport Canada and the U.S. NHTSA. Here is what both agencies say.
- Canadian recalls
- 03
- U.S. recalls
- 04
- Total campaigns
- 07
Transport Canada recalls
03- Accessories#2017590
19 units affected
On certain fire trucks, the retaining ring(s) in the relief valve assembly may not have been made using high grade stainless steel, causing it to deteriorate over time due to frequent exposure to water. If the retaining ring fails, the relief valve may break down and prevent the fire pump from building adequate pressure, which would increase the risk of injury during firefighting operations. Correction: Dealers or certified technicians will inspect and replace the retaining ring(s) as necessary.
- Steering#2017495
24 units affected
On certain vehicles, the steering assist cylinder attachment and adjustment points may not have been tightened to specification at time of assembly. This could result in the steering assist cylinder separating from the steering arm, causing a loss of steering assist and increasing the risk of a crash causing injury and/or damage to property. Correction: Vehicles will be inspected and fasteners tightened to specification.
- Suspension#2017213
3 units affected
On certain vehicles equipped with Reyco independent front suspension (IFS), the suspension system may contain loose ball joints. If these are not detected through regular servicing, they may separate, causing suspension failure. This could affect vehicle handling and increase the risk of a crash causing injury and/or damage to property. Correction: Owners will be instructed the have the suspension inspected by an E-One certified dealer or technician. Loose ball joints will be replaced.
Canadian data updated August 24, 2026
U.S. NHTSA recalls
04- FUEL SYSTEM, DIESEL:FUEL INJECTION SYSTEM:FUEL RAIL#21V332000
E-One Incorporated (E-One) is recalling certain 2017-2021 Cyclone 2, Cyclone N, Quest 2, Typhoon, and Typhoon N vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will inspect and replace the rail as necessary, free of charge. Owner notification letters were mailed out on May 28, 2021. Owners may contact E-One customer service at 1-352-237-1122.
- ELECTRICAL SYSTEM:STARTER ASSEMBLY#19V730000
E-One Incorporated (E-One) is recalling certain 2013-2019 Typhoon and Cyclone 2, 2013-2014 Cyclone 3, 2014-2019 Quest 2 and 2017 CHSH emergency vehicles equipped with a Cummins ISL, L9, ISX12, X12, ISX15, or X15 engine. The engines do not have a diode in the starter solenoid circuit to improve the longevity of the lock-out relay, resulting in accumulated damage over time.
Risk: The damaged starter lock-out relay may prevent the vehicle from starting, hindering personnel from responding to emergencies, increasing the risk of an injury.
Remedy: E-One will notify owners, and dealers will install a diode in the starter solenoid circuit and install a new starter lock-out relay, free of charge. The recall began November 15, 2019. Owners may contact E-One customer service at 1-352-861-3612. Note: Vehicles previously repaired under recall 18V-019 also need this recall remedy.
- EXTERIOR LIGHTING:BRAKE LIGHTS#18V606000
E-One Incorporated (E-One) is recalling certain 2017-2019 Cyclone II, Typhoon and Quest II emergency vehicles, equipped with Whelen accessory brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Remedy: E-One will notify owners, and dealers will replace the brake lights, free of charge. The recall began October 26, 2018. Owners may contact E-One customer service at 1-352-861-3612.
- ELECTRICAL SYSTEM:STARTER ASSEMBLY#18V019000
E-One Incorporated (E-One) is recalling certain 2013-2017 Cyclone II, Typhoon, and Quest II emergency vehicles equipped with a Cummins ISL, L9, ISX15, or X15 engine. The affected engines do not have a diode in the starter solenoid circuit to improve the longevity of the lock-out relay, resulting in accumulated damage over time.
Risk: The damaged starter lock-out relay may prevent the vehicle from starting, hindering personnel from responding to emergencies.
Remedy: E-One will notify owners, and dealers will install a diode in the starter solenoid circuit and install a new starter lock-out relay, free of charge. The recall began on February 19, 2018. Owners may contact E-One customer service at 1-352-861-3612.
Does this recall apply to my vehicle?
Matched by make, model, and model year. Many recalls affect only specific VIN ranges — confirm with your dealer using your full VIN.
What to do
Recall repairs are free at a franchised dealer in both countries. To confirm a recall applies to your specific vehicle, or to book the work, contact your manufacturer or dealer with your full VIN, or use the official channel:
- NHTSA recall lookup (search by VIN) — U.S. National Highway Traffic Safety Administration
- Defects and recalls database — Transport Canada
Check a 2017 E-ONE Quest II VIN
A VIN decode confirms your vehicle's exact model year, trim and assembly plant, then runs this same recall check against it.